IC-A110 Service Manual - shercoares.org

SERVICE MANUAL

VHF AIR BAND TRANSCEIVER

iA110

INTRODUCTION

DANGER

This service manual describes the latest service information for the IC-A110 VHF AIR BAND TRANSCEIVER at the time of publication.

NEVER connect the transceiver to an AC outlet or to a DC power supply that uses more than 16 V. This will ruin the transceiver.

MODEL

VERSION General General-1 U.S.A. U.S.A.-1

IC-A110

SYMBOL GEN GEN-1 USA USA-1

To upgrade quality, any electrical or mechanical parts and internal circuits are subject to change without notice or obligation.

DO NOT expose the transceiver to rain, snow or any liquids. DO NOT reverse the polarities of the power supply when connecting the transceiver. DO NOT apply an RF signal of more than 20 dBm (100 mW) to the antenna connector. This could damage the transceiver’s front end.

ORDERING PARTS

REPAIR NOTES

Be sure to include the following four points when ordering replacement parts:

1. Make sure a problem is internal before disassembling the transceiver. 2. DO NOT open the transceiver until the transceiver is disconnected from its power source. 3. DO NOT force any of the variable components. Turn them slowly and smoothly. 4. DO NOT short any circuits or electronic parts. An insulated tuning tool MUST be used for all adjustments. 5. DO NOT keep power ON for a long time when the transceiver is defective. 6. DO NOT transmit power into a signal generator or a sweep generator. 7. ALWAYS connect a 50 dB to 60 dB attenuator between the transceiver and a deviation meter or spectrum analyzer when using such test equipment. 8. READ the instructions of test equipment thoroughly before connecting equipment to the transceiver.

1. 10-digit order numbers 2. Component part number and name 3. Equipment model name and unit name 4. Quantity required 1130008830 S.IC TB31207AFN IC-A110 MAIN UNIT 5 pieces 8810009130 Screw BT M3x12 NI-ZU IC-A110 Bottom cover 10 pieces

Addresses are provided on the inside back cover for your convenience.

TABLE OF CONTENTS SECTION 1

SPECIFICATIONS

SECTION 2

INSIDE VIEWS

SECTION 3

CIRCUIT DESCRIPTION

3-1

RECEIVER CIRCUITS............................................................................................................................. 3 - 1

3-2

TRANSMITTER CIRCUITS ..................................................................................................................... 3 - 3

3-3

PLL CIRCUITS......................................................................................................................................... 3 - 4

3-4

POWER SUPPLY CIRCUITS .................................................................................................................. 3 - 5

3-5

PORT ALLOCATIONS ............................................................................................................................. 3 - 5

SECTION 4

ADJUSTMENT PROCEDURES

4-1

PREPARATION ....................................................................................................................................... 4 - 1

4-2

PLL ADJUSTMENT.................................................................................................................................. 4 - 3

4-3

TRANSMITTER ADJUSTMENT .............................................................................................................. 4 - 3

4-4

RECEIVER ADJUSTMENT...................................................................................................................... 4 - 5

SECTION 5

PARTS LIST

SECTION 6

MECHANICAL PARTS AND DISSASEMBLY

SECTION 7

SEMI-CONDUCTOR INFORMATION

SECTION 8

BOARD LAYOUTS

8-1

FRONT UNIT ........................................................................................................................................... 8 - 1

8-2

MAIN UNIT............................................................................................................................................... 8 - 3

SECTION 9

BLOCK DIAGRAM

SECTION 10

VOLTAGE DIAGRAM

10 - 1

FRONT UNIT ..........................................................................................................................................10 - 1

10 - 2

MAIN UNIT..............................................................................................................................................10 - 2

SECTION 1

SPECIFICATIONS

‘ GENERAL • Frequency coverage

: 118.000–136.975 MHz

• Channel spacing

: 25 kHz [GEN], [GEN-1] 25 kHz/8.33 kHz [USA], [USA-1]

• Type of emission

: AM (6K00A3E)

• Number of memory channels

: 20 channels

• Antenna connector

: SO-239 (50 Ω)

• Power supply requirement

: 13.75 V DC or 27.5 V DC (negative ground)

• Current drain (at 13.75 V DC)

: Transmit Receive

5.0 A 4.0 A 500 mA

max. audio output stand-by

• Frequency stability

: ±5 ppm

• Usable temperature range

: –30˚C to +60˚C; –22˚F to +140˚F

• Dimensions (projections not included)

: 150(W) × 50(H) × 180(D) mm; 529⁄32(W) × 131⁄32(H) × 73⁄32(D) in

• Weight (with ant., BP-209)

: 1.5 g; 3 lb 5 oz

‘ TRANSMITTER • RF output power (at 13.75 V DC)

: 9.0 W (typical)

• Modulation system

: Last stage modulation

• Input impedance

: 600 Ω

• Modulation limitting

: 70–100 %

• Audio harmonic distortion

: Less than 10 % (at 85 % modulation)

• Ham and noise ratio

: More than 40 dB

• Spurious emissions

: –16 dBm or less (except ±62.5 kHz of operating frequency)

• Antenna requirements

: Standard 50 Ω antenna with a VSWR < 3 : 1

‘ RECEIVER • Receive system

: Double conversion superheterodyne system

• Intermediate frequencies

: 1st 2nd

• Sensitivity

: Less than 1 µV at 6 dB S/N

• Squelch sensitivity

: Less than 0.35 µV at threshold

• Selectivity

:

38.85 MHz 450 kHz

At 25 kHz channel spacing ±8 kHz Less than 6 dB

At 8.33 kHz channel spacing ±2.778 kHz Less than 6 dB

±17 kHz

Less than 40 dB

±7.37 kHz

±25 kHz

Less than 60 dB

Less than 60 dB

• Spurious response rejection ratio

: More than 74 dBµ

• Hum and noise

: More than 25 dB

• Audio output power (at 13.75 V DC)

: Ext SP Side tone

More than 10.0 W at 10 % distortion with an 8 Ω load More than 100 mW at 10 % distortion with an 500 Ω load

• Audio output impedance

: Ext SP Side tone

8Ω 500 Ω

Specifications are measured in accordance with FCC Part87 and RTCA DO-186a. (RTCA DO-186a: Class C/E, Class 4/6) All stated specifications are subject to change without notice or obligation.

1-1

SECTION 2

INSIDE VIEWS

¡MAIN UNIT

Power complifier (Q51: MRF137) Low-pass filter Antenna switching circuit

APC amplifier (Q11: 2SC4081)

VCO circuit

Crystal band pass filter (FI2: FL-307 [USA/-1] only) Crystal band pass filter (FI1: FL-306)

TCXO (X1: CR-653)

Ceramic band pass filter (FI3: CFWM450D) Ceramic band pass filter (FI4: CFG450H [USA/-1] only)

Low-pass filter Antenna switching circuit

AF amplifier (IC37: TDA7233D)

RX 1st mixer (Q2: 3SK184)

2nd IF IC (IC40: TA31136FN) EEPROM (IC4: BA3308F)

PWM modulator (IC44: µPC311)

PLL IC (IC2: TB31207AFN)

AF power amplifier (Q92,93: 2SK2414)

2-1

SECTION 3

CIRCUIT DESCRIPTION

3-1 RECEIVER CIRCUITS

3-1-3 1ST MIXER AND 1ST IF CIRCUITS

3-1-1 ANTENNA SWITCHING CIRCUIT

The 1st mixer circuit converts the received signal into a fixed frequency of the 1st IF signal with a PLL output frequency. By changing the PLL frequency, only the desired frequency will pass through a crystal filter at the next stage of the 1st mixer.

The antenna switching circuit functions as a low-pass filter while receiving. However, its impedance becomes very high while D1 and D2 are turned ON. Thus transmit signals are blocked from entering the receiver circuits. The antenna switching circuit employs a λ⁄4 type diode switching system. The passed signals are then applied to the RF amplifier circuit.

The filtered signals from the RF circuit are mixed at the 1st mixer (Q2) with a 1st LO signal coming from the VCO circuit to produce a 38.85 MHz 1st IF signal.

Received signals are passed through the low-pass filter (L2, L3, L48, C1–C6, C330, C331). The filtered signals are applied to the λ⁄4 type antenna switching circuit (D1, D2).

The 1st IF signal is applied to a pair of crystal filter [Wide mode: FI1, Narrow mode: FI2] to suppress out-of-band signals. The filtered 1st IF signal is applied to the IF amplifier (Q3), then applied to the 2nd mixer circuit (IC40, pin 16).

3-1-2 RF CIRCUIT The RF circuit amplifies signals within the range of frequency coverage and filters out-of-band signals.

3-1-4 2ND MIXER AND 2ND IF CIRCUITS The 2nd mixer circuit converts the 1st IF signal into a 2nd IF signal. A double conversion superheterodyne system (which converts receive signals twice) improves the image rejection ratio and obtains stable receiver gain.

The signals from the antenna switching circuit are amplified at the RF amplifier (Q1) after passing through the RX attenuator (D38, L52, R295), bandpass filter (L27, L8, C10, C164, C165, C21) and two-stage tunable bandpass filters (the first filter is consisted of D6, L9, C342, C405 and the second filter is consisted of D37, L49, C23, C406). The amplified signals are applied to the 1st mixer circuit (Q2, gate 1) after out-of-band signals are suppressed at the another two-stage tunable bandpass filters (D7, L10, C28, C407 and D8, L11, C61, C553).

The 1st IF signal from the IF amplifier is applied to the 2nd mixer section of the IF IC (IC2, pin 16), and is mixed with the 38.4 MHz 2nd LO signal to be converted into a 450 kHz 2nd IF signal. A 2nd LO signal (38.4 MHz) is produced at the PLL circuit by tripling it’s reference frequency (12.8 MHz).

The tunable bandpass filters (D6–D8, D37) which employ varactor diodes, track the filters and are controlled by the PLL IC (IC2) via the tune buffer amplifier (Q79) using “TUNE” signal. These diodes tune the center frequency of an RF passband for wide bandwidth receiving and good image response rejection.

The 2nd IF signal from the 2nd mixer (IC2, pin 3) passes through a ceramic filter [Wide mode: FL3, Narrow mode: FI4] to remove unwanted heterodyned frequencies. It is then amplified at the 2nd IF amplifiers (Q4–Q6).

• Receiver construction 118.000–136.975 MHz

LPF

D1–D3

D38

Ant SW

ATT

D6, D37 Tuned BPF

BPF

D7, D8 Tuned BPF

Q1 RF AMP

1st mixer Q2

FI1 [Wide], FI2 [Narrow] 38.85 MHz Q3 XTAL IF BPF AMP

1st LO signal 79.15–98.125 MHz from VCO circuit 12.8 MHz signal from TCXO (X1) "TUNE" signal Tripler Q83, Q84

to AF circuit

AM DET

IF AMP Q6

3-1

IF AMP Q4, Q5

450 kHz XTAL BPF FI3 [Wide], FI4 [Narrow]

3 2nd LO signal 38.4 MHz

2nd IF IC

3-1-5 AM DETECTOR CIRCUIT (MAIN UNIT)

3-1-7 SQUELCH CIRCUIT (MAIN AND FRONT UNITS)

The AM detector circuit converts the 2nd IF signal into AF signals.

The squelch circuit cuts out AF signals when receiving no modulated signal. When no voice modulation is included in the signal, the squelch circuit cuts out the AF signal by comparing voice audio and noise audio components in the AF detected signals.

The amplified 2nd IF signal from the 2nd IF amplifier (Q6) is applied to the AM detector circuit (Q7). It is then detected for conversioin to AF signals. The AF signals are applied to the AF circuit.

The 2nd IF signal from the IF IC (MAIN unit; IC40, pin 3) passes through the 450 kHz ceramic filter (Wide mode: FI3, Narrow mode: FI4) to remove out-of-band signals, and then applied to the IF amplifier.

3-1-6 AF CIRCUIT (MAIN UNIT) The AF circuit amplifies the demodulated AF signals to drive a speaker.

A portion of the amplified 2nd IF signal from the IF amplifier (MAIN unit; Q4) is applied to the IF amplifier section on the IF IC (MAIN unit; IC40, pin 5). The amplified signal passes through the RSSI section, and are then applied to the squelch amplifier (MAIN unit; IC11, pin 1) as “RSSI” signal.

The AF signals are passed through the low pass filter (IC31, pin 1), and then applied to the MOD/AF select swtich (IC22, pin 7).

The amplified “RSSI” signal at IC11 is output from pin 4 as “SQLI” signal, and is then applied to the CPU (FRONT unit; IC1, pin 74). The CPU analyzes the noise condition and outputs the “AFMUT” signal via the output expander IC (FRONT unit; IC5) to switch the SP mute switch (Q100, Q101), etc. When connecting the head set, “RMUTE” signal from the CPU via the output expander IC (FRONT unit; IC5) is applied to the RMUTE circuit (MAIN unit; IC6, Q80, Q81).

The AF signals are amplified at the AF amplifier (IC42, pin 3), and are then passed through the RMUTE swtich (IC6) and electric-volume switch (IC13, pins 14, 15) to control AF level. The level controlled signals are then applied to the mute switch (IC30, pin 1). While in using the internal speaker or connecting outer speaker jack, the AF signals are applied to the MOD/AF swtich (IC48, pin 7) via the AF mute swtich (IC28). The applied AF signals are compared at the PWM IC (IC44) with the reference signal from the triangular wave oscillator (IC45), and are then converted to the PWM wave form. The AF signals are amplified at the FET driver (IC47) and AF power amplifiers (Q92, Q93). The amplified AF signals are applied to the SP mute switch (D66, Q101, Q100) via the line filter (L62–L64, L81, C456, C457, C462, C463). The filtered AF signals are applied to the internal speaker via the [EXT SP] jack (J7).

Even when the squelch is closed, the mute switch (IC30) opens at the moment of emitting beep tones.

3-1-8 AGC CIRCUIT (MAIN UNIT) The AGC (Automatic Gain Control) circuit reduces signal fading and keeps the audio output level constant. AF signal from the AM detector circuit (Q7) is amplified at AGC amplifiers (Q77, Q78). The amplified signal from Q77 is applied to the IF amplifier (Q4, Q5). The other amplified signal from Q78 is applied to the RF amplifier (Q1), and the RX attenuator (D38) via the buffer amplifier (Q73).

While in connecting the head set, the AF signals are amplified at the AF power amplifier (IC37, pin 8), and then applied to the ACC connector (J6, pin 6) via the impedance convertor (T1).

These amplifiers reduce the amplifier gain of IF amplifiers (Q4, Q5) and the RF amplifier (Q1) while receiving a strong signal.

• AGC circuit D38 From the ant.

Q1 RF AMP

RX ATT

1st mixer Q2

Q3 XTAL BPF

IF AMP

2nd mixer IC40

Q4, Q5 BPF

IF AMP

Q6 IF AMP

D7 AM DETECTOR

Q77 Q73

"IF AGC" signal

AGC AMP

Buffer

Q78 AGC AMP

"RF AGC" signal

to AF circuit

3-2

3-2-3 DRIVE/POWER AMPLIFIER CIRCUITS (MAIN UNIT)

3-2 TRANSMITTER CIRCUITS 3-2-1 MICROPHONE AMPLIFIER CIRCUIT (MAIN UNIT)

The amplifier circuit amplifies the VCO oscillating signal to the output power level.

The microphone amplifier circuit amplifies audio signals from the microphone, within +6 dB/octave pre-emphasis characteristics (300 Hz–3 kHz), to a level needed for the modulation circuit.

The signal from the buffer amplifiers (Q14, Q15) is passed through the TX/RX switch (D11), and is amplified at the preamplifier (Q42), pre-drivers (Q20, Q21) and the power amplifier (Q51) to obtain 9 W of RF power.

The AF signals from the microphone are applied to the IN/EXT MIC switch (IC16, pin 7) via the “MIC” signal. When using a headset, “EXTMIC” signal are applied to the external switch (IC16, pin 6) via R336 to adjust the external microphone level. The output signal from IC16 (pin 1) are applied to the ALC amplifier (IC4, pin 9) via R110 to adjust the microphone sensitivity.

The amplified signal is passed through the antenna swtiching circuit (D3) and low-pass filter, and is then applied to the antenna connector.

3-2-4 APC CIRCUIT (MAIN UNIT) The APC (Automatic Power Control) circuit protects the drive and power amplifiers from mismatched output loads.

The output signal from IC4 (pin 7) are amplified at the AF amplifier (IC5), and then applied to the MOD/AF switch via the high-pass filter (IC51) and low-pass filter (IC19) to filter out RF components. The filtered signals are applied to the modulation circuit.

The APC detector circuit (D4, D5) detects forward and refrected signals respectively. The combined voltage is at a minimum level when the antenna is matched at 50 Ω and is increased when it is mismatched.

3-2-2 MODULATION CIRCUIT (MAIN UNIT) The detected voltage is applied to one of the APC controller inputs (IC50, pin 3) and a power setting voltage is applied to the other input (pin 1). When the antenna impedance is mismatched, the detected voltage exceeds the reference voltage. Thus the bias voltage of the pre-drivers is decreased.

The modulation circuit modulates the VCO oscillating signal (RF signal) using the microphone AF signal. The audio signals are passed through the MOD/AF switch (IC48, pin 6) via the modulation depth adjustment pot R121. The signals are converted to the PWM wave form at the PWM (Pulse-Width-Modulation) IC (IC44, pin 3), and power amplified at the FET driver (IC47, pin 5) and power MOS FET (Q92, Q93). The power-amplified signals are passed through the line filter (L62–L64, L81, C456, C457, C462, C463, C468), and then applied to the drain of power amplifier (Q51) for the last stage modulation.

• APC control circuit

"MOD V" signal from the AF power amplifiers (MAIN unit; Q92, Q93) Q51 Power detector circuit Q21 L6 PRE PWR DRIVE AMP C14 C13

Pre-amplified signal Q20 (from MAIN unit; Q42) PRE DRIVE

C17

C16 D4

D5 R3

R2

C18

Q98 PWR CNT

L75

C19

IC50

Q11 APC AMP

to the Antenna

APC CNT

R148

R153

C139

Q99 "TMUT" signal from the expander IC (Front unit; IC5; pin 14)

R149

R151 T8

R150 (Power adjustment)

3-3

3-3 PLL CIRCUIT

3-3-3 RX LOOP

3-3-1 GENERAL (MAIN UNIT)

The generated signal at the RX-VCO (Q59, D65) enters the PLL IC (IC2, pin 8), and is divided at the programmable divider section. The divided signal is then applied to the phase detector section.

A PLL circuit provides stable oscillation of the transmit frequency and receive 1st LO frequency. The PLL output compares the phase of the divided VCO frequency to the reference frequency. The PLL output frequency is controlled by the divided ratio (N-data) of a programmable divider.

The phase detector compares the input signal with a reference frequency, and then outputs the out-of-phase signal (pulse-type signal) from pin 9.

The PLL circuit contains of the TX-VCO and RX-VCO circuits. The oscillated signals are applied to the buffer amplifiers (Q43, Q12) then applied to the PLL IC (IC2, pin 8). IC2 is a dual PLL IC which controls VCO circuits for TX and RX.

The pulse-type signal is converted into DC voltage (lock voltage) at the loop filter (R61, R62, C59, C60), and then applied to the varactor diode (D65) of the RX-VCO to stabilize the oscillated frequency. The lock voltage is also used for the receiver circuit for the bandpass filter center frequency. The lock voltage from the PLL IC (IC2, pin 9) passes through the low-pass filter, and is applied to the tune buffer amplifier (Q79). The amplified signal is applied to the RF bandpass filters (D7, D8 and D6, D37) via the tune adjustment pot (R59).

The PLL circuit, using a one chip PLL IC (IC2), directly generates the transmit frequency and receive 1st IF frequency with VCOs. The PLL sets the divided ratio based on serial data from the CPU on the FRONT unit and compares the phases of VCO signals with the reference oscillator frequency. The PLL IC detects the out-of-step phase and output from pin 9 for TX and RX, respectively. The reference frequency (12.8 MHz) is oscillated at X1.

3-3-4 VCO CIRCUIT The generated signal at the TX-VCO (Q44, D64) enters the PLL IC (IC2, pin 8), and is divided at the programmable divider section and is then applied to the phase detector section.

The VCO outputs from Q44 (TX) and Q59 (RX) are buffer amplified at Q43, and are applied to the buffer amplifiers (Q14, Q15). The amplified signal is applied to the T/R switch (D10, D11). The receive LO signal is applied to the 1st mixer circuit (Q2), and the transmit signal is applied to the preamplifier (Q42).

The phase detector compares the input signal with a reference frequency, and then outputs the out-of-phase signal (pulse-type signal) from pin 9.

A portion of the VCO signal is amplified at the buffer amplifier (Q12), and then fed back to the PLL IC (IC2, pin 8).

3-3-2 TX LOOP

The pulse-type signal is converted into DC voltage (lock voltage) at the loop filter (R61, R62, C59, C60), and then applied to the varactor diode (D64) of the TX-VCO to stabilize the oscillated frequency.

• PLL circuit

to transmitter circuit TX VCO Q44, D64

Q14

Q15

Buff.

Buff.

D11 to 1st mixer circuit (Q2)

Q43 D10

Buff.

RX VCO

Q12 Buff.

Q59, D65

Loop filter

TX/RX switch

IC2 (PLL IC) Phase detector

9

Programmable counter

Programmable divider

TCXO (X1) 12.8 MHz

Prescaler

Shift register

8 3 4 5

SCK SO PLSTB

14 3 Q83, Q84 LPF

38.4 MHz 2nd LO signal to the 2nd IF IC (IC40, pin 2) Q79 Tune buff.

to the RF BPF (D7 and D8, D6 and D37)

R59 (RF BPF adjustment)

3-4

3-4 POWER SUPPLY CIRCUITS

3-5 PORT ALLOCATIONS

VOLTAGE LINES (MAIN UNIT)

3-5-1 OUTPUT EXPANDER IC (FRONT unit: IC5)

LINE

DESCRIPTION

VCC

The voltage from the external DC power connector which is controlled by the power switch ([VOL] control).

8V

Common 8 V converted from the VCC line by the +8 V regulator circuit (IC29). The output voltage is applied to the +5 V regulator circuit (IC7), the ripple filter (Q16), and etc.

+5V

Common 5 V converted from the 8V line by the +5V regulator (IC7) and +5V current amplifier (Q22, Q23, D15) circuits. The output voltage is applied to the electric volume IC (IC13), buffer amplifiers (Q68, Q69), and etc.

CPU5V

Pin number

8 V for transmitter circuits regulated by the +8 V regulator circuit (IC29).

R8

8 V for receiver circuits regulated by the +8 V regulator circuit (IC29).

Description Outputs backlight control signals. LED1 LED2

4, 5

LED1, LED2

Low

Low

High Low

Backlight condition Light OFF No establishment

Low High Light ON, Dimmer ON High High Light ON, Dimmer OFF

TRC

Outputs control signal to the MOD/AF swtich (MAIN unit: IC48, pin 5) and etc. High: While transmitting.

R/T

Outputs control signal to the TX/RX switch (MAIN unit: Q58, pin 1) for VCO. Low: While transmitting.

SMUT

Outputs AF mute swtich (MAIN unit: IC30, Q86, Q75, Q74, D43) control signal. Low: While squelched.

12

AFMUT

Outputs control signal to the mute switch (MAIN unit; Q100, Q101, D66) for speaker amplifier, and etc. Low: While the speaker output is muted.

13

RMUT

Outputs RMUTE switch (IC6) control signal. Low: While squelched.

14

TMUT

Outputs T8 regulator control signal. Low: When TX is muted.

6

Common 5 V converted from the VCC line by +8 V regulator (Q82, D35) and +5 V regulator circuits (IC26). The output 5 V voltage is applied to the CPU (FRONT unit; IC1).

T8

Port name

7

11

3-5

3-5-2 CPU (FRONT unit; IC1) Pin number

Port name

1, 2, 3, 5, 8, 12

KR4

9

RESET

Input port for the CPU reset signal.

PSWC

Outputs control signal for the power supply circuit. High: Power is ON.

10

Description Input ports for the key matrix.

11

BEEP

13

ECK

Outputs clock signal to the EEPROM (FRONT unit; IC4, pin 6).

14

ESO

Outputs data signal to the EEPROM (FRONT unit; IC4, pin 5).

15

ECS

Outputs chip select signal to the EEPROM (FRONT unit; IC4, pin 1).

16, 17

DLA, DLB

Input port for the [DIAL] control signal.

18

OE

Outputs control signal to the expander IC (FRONT unit; IC5, pin 15).

19

EXSTB

Outputs strobe signals to the expander IC (FRONT unit; IC5, pin 1).

20

VCS

Outputs chip select signal to the electric volume (MAIN unit; IC13). Low: While volume is controlled.

21

SCK

Outputs serial clock to the PLL IC (MAIN unit; IC2, pin 3), the expander IC (FRONT unit; IC5, pin 3) and the electric volume (MAIN unit; IC13, pin 8).

22

ESI

Input port for the data signal from the EEPROM (FRONT unit; IC4, pin 2).

23

SO

Outputs serial data to the PLL IC (MAIN unit; IC2, pin 4), the expander IC (FRONT unit; IC5, pin 2) and the electric volume (MAIN unit; IC13, pin 9).

24

PLSTB

Outputs strobe signals to the PLL IC (MAIN unit; IC2, pin 5).

25

FISW

Outputs 2nd IF filter’s select signal. High: While wide is selected.

69

UNLK

Input port for the unlock signal from the PLL IC (MAIN unit; IC2, pin 11). Low: PLL is unlocked.

70

CLIN

Input port for the cloning signal.

71

CLO

Output port for the cloning signal.

72

PSW

Input port for the POWER switch. Low: While POWER switch pushed

74

SQLI

Input port for the squelch signal.

Pin number

Port name

Description

76

HANG

Input port for the microphone hanger detection signal. Low: Microphone on hook.

77

PTT

78–80

Outputs beep audio signals.

is

3-6

Input port for the PTT switch. High: While PTT switch is pushed.

KR1–KR2 Input ports for the key matrix.

SECTION 4 ADJUSTMENT PROCEDURES 4-1 PREPARATION • Some versions may need the optional CS-A110 CLONING SOFTWARE and OPC-478, OPC-592 CLONING CABLE for setting the adjustment frequency. • All adjustments must be performed on the [Wide] mode.

■ REQUIRED TEST EQUIPMENT EQUIPMENT

GRADE AND RANGE

EQUIPMENT DC power supply

Output voltage Current capacity

: 13.75 V DC : 10 A or more

RF power meter (terminated type)

Measuring range Frequency range Impedance SWR

: : : :

Frequency counter

Frequency range : 0.1–300 MHz Frequency accuracy : ±1 ppm or better Sensitivity : 100 mV or better

1–50 W 50–300 MHz 50 Ω Less than 1.2 : 1

DC voltmeter

GRADE AND RANGE Input impedance

: 50 kΩ/V DC or better

Digital multimeter

Input impedance

: 10 MΩ/V DC or better

Audio generator

Frequency range Measuring range

: 300–3000 Hz : 1–500 mV

Frequency range Output level

: 0.1–300 MHz : 0.1 µV–32 mV (–127 to –17 dBm)

AC millivoltmeter

Measuring range

: 10 mV–10 V

Standard signal generator (SSG)

Modulation analyzer


: DC–300 MHz : 0 to 100 %

Attenuator

Power attenuation Capacity

: 40 or 50 dB : 50 W or more

Distortion meter


: 1 kHz±10 % : 1 to 100 %

Terminator

Impedance Capacity

: 50 Ω : 50 W or more

External speaker

Impedance

:8Ω

■ VFO CHANNEL ID LIST • Channel spacing: 8.33/25 kHz [USA/USA-1]

• Channel spacing: 25 kHz [GEN/GEN-1]

Operating Freq. (MHz)

Channel spacing (kHz)

Channel ID (Displayed Freq.)

Operating Freq. (MHz)

Channel spacing (kHz)

Channel ID (Displayed Freq.)

118.0000

25

118.000

118.0000

25

118.000

118.0000

8.33

118.005

118.0250

25

118.025

118.0083

8.33

118.010

118.0500

25

118.050

118.0167

8.33

118.015

118.0750

25

118.075

118.0250

25

118.020

118.1000

25

118.100

118.0250

8.33

118.030

etc

118.0333

8.33

118.035

118.0417

8.33

118.040

118.0500

25

118.050

118.0500

8.33

118.055

118.0583

8.33

118.060

118.0667

8.33

118.065

118.0750

25

118.070

118.0750

8.33

118.080

118.0833

8.33

118.085

118.0917

8.33

118.090

118.1000

25

118.100

118.1000

8.33

118.105

etc

4-1

■ CONNECTION Modulation analyzer

Attenuator 40 dB or 50 dB

Power supply DC 13.75 V, 10 A

CAUTION! DO NOT transmit while an SSG is connected to the antenna connector.

Distortion meter to the external speaker jack

Standard signal generator (SSG) 0.1–300 MHz –127 to –17 dBm (0.1 µV to 32 mV)

to the antenna connector

RF power meter 50 Ω, 1–50 W

Frequency counter

AC millivoltmeter

Speaker (8 Ω)

• MIC JACK PIN CONNECTION Pin 4 (PTT) Pin 5 (MICE

)

Pin 7 (GND) Audio generator Pin 6 (MIC

)

AC millivoltmeter

1

2

3

4

5

6

7

8

AC millivoltmeter

to the microphone connector

Audio generator 300 Hz to 3 kHz

OPC-592 Cloning connection

DB9 female plug OPC-478

(incl. level converter circuit)

Personal computer to an RS-232C port

4-2

4-2 PLL ADJUSTMENT ADJUSTMENT

ADJUSTMENT CONDITION

MEASUREMENT UNIT

LOCATION

VALUE

ADJUSTMENT POINT UNIT

ADJUST

Vdd VOLTAGE

1 • Operating frequency : 118.000 MHz • Receiving

MAIN

Connect a digital multi-meter to drain terminal of Q51.

13.5 V

MAIN

R392

PLL LOCK VOLTAGE


MAIN

Connect a digital multi-meter to the check point CP2.

0.5 V

MAIN

L41

MAIN

Connect a digital multi-meter to the check point CP1.

0.7 V

MAIN

R59

Rear panel

Loosely couple the frequency counter to the antenna connector.

136.9500 MHz

MAIN

X1

0.5 V

2 • Transmitting TUNE VOLTAGE


REFERENCE 1 • Operating frequency : FREQUENCY 136.950 MHz • Connect an RF power meter or a 50 Ω dummy load to the antenna connector. • Transmitting

L40

4-3 TRANSMITTER ADJUSTMENT ADJUSTMENT


MEASUREMENT UNIT

LOCATION

1 • Operating frequency : 127.000 MHz • No audio applied to the [MIC] jack. • Transmitting

Rear panel

Connect an RF power meter to the antenna connector.

MODULATION 1 • Operating frequecy : DEPTH 127.000 MHz • Connect an audio generator to the [MIC] jack and set as : 1 kHz/10 mVrms • Set a modulation analyzer as : HPF : OFF LPF : OFF De-emphasis : OFF Detector : (P–P)/2 • Pre-set R110 and R121 on the MAIN unit to the center position. • Transmitting

Rear panel

Connect a modulation analyzer to the antenna connector through an attenuator.

OUTPUT POWER


ADJUST

9.0 W

MAIN

R150

90 %

MAIN

R121

30 %

2 • Set an audio generator as: 1 kHz/1 mVrms • Transmitting HEAD SET 1 • Operating frequency : MODULATION 127.000 MHz • Connect an audio generator to the [EXT MIC] jack and set as : 1 kHz/1 mVrms • Transmitting

VALUE

Rear panel

Connect a modulation analyzer to the antenna connector through an attenuator.

4-3

30 %

R110

MAIN

R336

pin 4 (

GND)

pin 5 (

PTT)

pin 2 (

MICE)

pin 3 (

MIC)

Audio generator

J6, pin 3 DC power supply 13.75 V/10 A

Audio input point

R336 Head set modulation adjustment

Q51 Vdd voltage check point

R59 TUNE voltage adjustment

CP1 TUNE voltage check point

R150 Output power adjustment

L40 PLL lock voltage adjustment for TX

L41 PLL lock voltage adjustment for RX

CP2 PLL lock voltage check point

R392 Vdd voltage adjustment

X1 Reference frequency adjustment

R121 R110 Modulation depth adjustment

4-4

4-4 RECEIVER ADJUSTMENT “SQUELCH ADJUSTMENT” must be performed at “SQUELCH ADJUSTMENT MODE”.

ADJUSTMENT


RX 1 • Operating frequency : SENSITIVITY 118.000 MHz • Pre-set L9, L10, L11, L49 on the MAIN unit to max. CCW. • Connect an SSG to the antenna connector and set an SSG as : Level : 1.0 µV* (–107 dBm) Modulation : ± 1 kHz Mod. depth : 30 % • Receiving

MEASUREMENT UNIT

LOCATION

Rear panel

Connect an AC millivoltmeter and distortion meter with 8 Ω load to the external [SP] jack.

2 • Operating frequency : 136.975 MHz • Receiving SQUELCH

1 • Enter the “Squelch adjustment mode”. 1): Program 118.000 MHz into memory channel. 2): Turn power OFF. 3): While pushing [SQL], [TS], [SCAN], turn power ON. • Connect an SSG to the antenna connector and set an SSG as : Level : 0.18 µV* (–122 dBm) Modulation : OFF • Receiving

VALUE Maximum AF output level

Maximum AF output level Front panel

Display


ADJUST

MAIN

L9, L10, L11, L49

R59

• Verify the display indicates “sqADJ02”. NOTE: If the display shows other, turn [MAIN DIAL] to select “sqADJ02”. • Push the [SCAN] key to set the threshold level.

• Verify the display indicates “sqADJ25”.

2 • Set an SSG as : Level : 5.6 µV* (–92 dBm) Modulation : OFF

• Push the [SCAN] key to set the tight level.

3 • Turn power OFF to cancell the “Squelch adjustment mode”. NOTE: Until turn power OFF, “Squelch adjustment mode” is not cancelled, and once pushing the [SCAN] key, display indicates “sqADJ02” (threshold level adjustment) or “sqADJ25” (tight level adjustment) repeatedly *This output level of the standard signal generator (SSG) is indicated as SSG’s open circuit.

4-5

DC power supply 13.75 V/10 A

L11 L10 L49 L9 R59 RX sensitivity adjustment

4-6

SECTION 5 PARTS LIST [FRONT UNIT] REF NO.

[FRONT UNIT]

ORDER NO.

REF NO.

DESCRIPTION

IC1 IC2 IC3 IC4 IC5

1140008780 1130009110 1130007110 1130008670 1130007510

S.IC S.IC S.IC S.IC S.IC

HD6433823A19D S-80942ANMP-DD6-T2 TC7W04FU (TE12L) 25LC160T-I/SN BU4094BCFV-E1

Q1 Q2 Q3 Q4 Q5 Q6 Q7

1590000440 1510000880 1530003280 1590001980 1590000440 1590000680 1590000680

S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR

DTA143ZUA T106 2SA1622-6-TL 2SC4211-6-TL XP4315 (TX) DTA143ZUA T106 DTC114EUA T106 DTC114EUA T106

D5 D6

1790001280 S.DIODE 1750000130 S.DIODE

MA111 (TX) DA204U T107

X1

6060000600 S.CERAMIC

PBRC 3.68 AR

L1 L2

6200003960 S.COIL 6200003540 S.COIL

MLF1608A 1R0K-T MLF1608D R22K-T

R1 R2 R3 R4 R5 R6 R7 R8 R9 R10 R11 R12 R13 R14 R15 R16 R17 R18 R19 R20 R21 R22 R23 R24 R26 R27 R28 R29 R30 R31 R32 R33 R34 R36 R37 R38 R41 R42 R43 R44 R45 R46 R47

7030003800 7030003680 7030003680 7030003580 7030003580 7030003580 7030003580 7030003560 7030003680 7030003680 7030003370 7030003350 7030003350 7030003640 7030003590 7030003540 7030003620 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003680 7030003440 7030003680 7030003560 7030003560 7030003560 7030003560 7030003500 7030003600 7030003680 7030003680 7030003610 7030003610 7030003580 7030003580 7030003580 7030003610 7030003580

S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ ERJ3GEYJ

C1 C2 C3 C4

4030006860 4030006860 4030007090 4030007090

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C1608 C1608 C1608 C1608

105 104 104 153 153 153 153 103 104 104 271 181 181 473 183 682 333 104 104 104 104 104 104 104 104 104 102 104 103 103 103 103 332 223 104 104 273 273 153 153 153 273 153

V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V V

(1 MΩ) (100 kΩ) (100 kΩ) (15 kΩ) (15 kΩ) (15 kΩ) (15 kΩ) (10 kΩ) (100 kΩ) (100 kΩ) (270 Ω) (180 Ω) (180 Ω) (47 kΩ) (18 kΩ) (6.8 kΩ) (33 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (100 kΩ) (1 kΩ) (100 kΩ) (10 kΩ) (10 kΩ) (10 kΩ) (10 kΩ) (3.3 kΩ) (22 kΩ) (100 kΩ) (100 kΩ) (27 kΩ) (27 kΩ) (15 kΩ) (15 kΩ) (15 kΩ) (27 kΩ) (15 kΩ)

ORDER NO.

DESCRIPTION

C5 C6 C7 C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C35 C36

4030006860 4030007090 4030006850 4030006850 4030008560 4030008560 4030008890 4030011600 4030011600 4030011600 4030007090 4030011600 4030011600 4030006860 4030006860 4030011600 4030006860 4030011600 4550006480 4030011600 4030011600 4030011600 4550006250 4030006860 4030006860 4030007090 4030006860 4030006860 4030006860 4030006860 4030006860 4030006860

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

J1 J2

6510020510 S.CONNECTOR FH12-40S-0.5SV 6450001470 CONNECTOR 95003-2881

DS1 DS2 DS3 DS4 DS5 DS6 DS7

5030001740 5040002030 5040002030 5040002030 5040002030 5040002030 5040002030

S1

2250000420 ENCODER

EVQB2CFC620B

SP1

2510000880 SPEAKER

SME-45W

W1 W2 W3 W4 W6

7120000470 7120000470 7030003860 7030003860 8900007680

ERDS2T0 ERDS2T0 ERJ3GE JPW V ERJ3GE JPW V OPC-741 (N:40 L:55)

EP1 EP2

0910051553 PCB B 5319C 8930037960 LCD CONTACT SRCN-1705 ZSS

LCD S.LED S.LED S.LED S.LED S.LED S.LED

JUMPER JUMPER S.JUMPER S.JUMPER CABLE

C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 471K-T-A C1608 JB 1H 471K-T-A C1608 CH 1H 300J-T-A C1608 CH 1H 300J-T-A C1608 JB 1C 273K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 470J-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N TEMSVA 1C 475M-8L C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N TEMSVA 1A 106M-8L C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A

HLC7453-012400 CL-170Y-CD-T CL-170Y-CD-T CL-170Y-CD-T CL-170Y-CD-T CL-170Y-CD-T CL-170Y-CD-T

JB 1H 102K-T-A JB 1H 102K-T-A CH 1H 470J-T-A CH 1H 470J-T-A

S.=Surface mount

5-1

[MAIN UNIT] REF NO.

[MAIN UNIT]

ORDER NO.

REF NO.

DESCRIPTION

IC2 IC4 IC5 IC6 IC7 IC11 IC13 IC15 IC16 IC17 IC18 IC19 IC22 IC26 IC28 IC29 IC30 IC31 IC37 IC40 IC41 IC42 IC43 IC44 IC45 IC46 IC47 IC48 IC50 IC51

1130008830 1110003670 1110002750 1130004200 1180000800 1110002400 1130008370 1110005010 1130006220 1130006220 1130006220 1110003780 1130006220 1180000420 1130004200 1180002010 1130004200 1110002750 1110003250 1110003200 1110005030 1110002750 1190001210 1110005130 1110005100 1110005010 1190001210 1130006220 1110002750 1110002750

S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.REG S.IC S.IC S.IC S.IC IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC S.IC

TB31207AFN (EL) BA3308F-T1 TA75S01F (TE85R) TC4S66F (TE85R) S-81350HG-KD-T1 NJM2107F-TE1 TC9260F (HR) MC33063AD TC4W53FU (TE12L) TC4W53FU (TE12L) [USA/-1] only TC4W53FU (TE12L) [USA/-1] only NJM2902V-TE1 TC4W53FU (TE12L) TA78L05F (TE12R) TC4S66F (TE85R) BA08FP-E2 TC4S66F (TE85R) TA75S01F (TE85R) TDA7233D (TDA7233D013TR) TA31136FN (EL) TA8208H TA75S01F (TE85R) HIP4081AIB-E2 µPC311G2 NJM072BM-TE1 MC33063AD HIP4081AIB-E2 TC4W53FU (TE12L) TA75S01F (TE85R) TA75S01F (TE85R)

Q1 Q2 Q3 Q4 Q5 Q6 Q7 Q11 Q12 Q14 Q15 Q16 Q20 Q21 Q22 Q23 Q33 Q42 Q43 Q44 Q51 Q52 Q53 Q58 Q59 Q68 Q69 Q70 Q71 Q72 Q73 Q74 Q75 Q77 Q78 Q79 Q80 Q81 Q82 Q83 Q84 Q86 Q87 Q88 Q89 Q90 Q91 Q92 Q93 Q94

1580000420 1580000420 1530002600 1530002600 1530002600 1530002600 1530003280 1530002280 1530002560 1530002560 1530002930 1530002850 1560001100 1560001060 1530003280 1520000460 1590001980 1530002920 1530002920 1530002920 1590002840 1510000880 1590000980 1590001810 1530002920 1590001980 1590000980 1590000980 1590001940 1590001980 1530002060 1520000200 1530002060 1540000520 1540000520 1560000530 1590000720 1590000430 1530002280 1530002380 1530002380 1590001980 1560001120 1560001120 1590001170 1510001020 1560001120 1560001120 1560001120 1590002870

S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.FET S.TRANSISTOR TRANSISTOR S.FET S.FET S.FET S.FET

3SK184-R (TX) 3SK184-R (TX) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC4215-O (TE85R) 2SC4211-6-TL 2SC4081 T107 S 2SC4403-3-TL 2SC4403-3-TL 2SC4228 (M) -T1 R45 2SC4116-BL (TE85R) 2SK3074 (TE12L) 2SK3075 (TE12L) 2SC4211-6-TL 2SB1132 T100 R XP4315 (TX) 2SC4226-T2 R25 2SC4226-T2 R25 2SC4226-T2 R25 MRF137 2SA1622-6-TL DTB123EK T147 XP1113 (TX) 2SC4226-T2 R25 XP4315 (TX) DTB123EK T147 DTB123EK T147 DTC144EE TL XP4315 (TX) 2SC4081 T107 R 2SB798-T2 DK 2SC4081 T107 R 2SD1819A (TX) R 2SD1819A (TX) R 2SK880-GR (TE85R) DTA144EUA T106 DTC144EUA T106 2SC4081 T107 S 2SC4215-Y (TE85R) 2SC4215-Y (TE85R) XP4315 (TX) 2SK2414-Z-E1 2SK2414-Z-E1 XP1501-(TX) .AB 2SA1471R 2SK2414-Z-E1 2SK2414-Z-E1 2SK2414-Z-E1 FW215-TL

ORDER NO.

DESCRIPTION

Q96 Q97 Q98 Q99 Q100 Q101 Q102

1590000430 1590000430 1510000770 1530002850 1590002870 1590000430 1530002280

S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.TRANSISTOR S.FET S.TRANSISTOR S.TRANSISTOR

DTC144EUA T106 DTC144EUA T106 2SA1586-GR (TE85R) 2SC4116-BL (TE85R) FW215-TL DTC144EUA T106 2SC4081 T107 S

D1 D2 D3 D4 D5 D6 D7 D8 D10 D11 D14 D15 D26 D27 D28 D29 D30 D31 D35 D36 D37 D38 D43 D44 D50 D51 D52 D53 D54 D55 D56 D57 D62 D64 D65 D66

1750000510 1750000510 1750000510 1790001670 1790001670 1720000370 1720000370 1720000370 1790000620 1790000620 1790001330 1790001280 1790001340 1790001280 1750000580 1750000580 1750000580 1750000580 1730002460 1790000700 1720000370 1750000530 1750000260 1730002320 1750000530 1750000530 1750000530 1790001250 1790001250 1790000670 1790001340 1790000670 1790000670 1720000370 1720000370 1790000670

S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.VARICAP S.VARICAP S.VARICAP S.DIODE S.DIODE S.ZENER S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.ZENER DIODE S.VARICAP S.DIODE S.DIODE S.ZENER S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.DIODE S.VARICAP S.VARICAP S.DIODE

UM9401F UM9401F UM9401F RB706F-40T106 RB706F-40T106 HVU350TRF HVU350TRF HVU350TRF MA77 (TX) MA77 (TX) MA8036-L (TX) MA111 (TX) DE5SC6M-4061 MA111 (TX) 1SV307 (TPH3) 1SV307 (TPH3) 1SV307 (TPH3) 1SV307 (TPH3) MA8330-M (TX) DSA3A1 HVU350TRF 1SV271 (TPH3) 1SS352 (TPH3) MA8051-M (TX) 1SV271 (TPH3) 1SV271 (TPH3) 1SV271 (TPH3) MA2S111-(TX) MA2S111-(TX) SB07-03C-TB DE5SC6M-4061 SB07-03C-TB SB07-03C-TB HVU350TRF HVU350TRF SB07-03C-TB

FI1 FI2 FI3 FI4 FI5 FI6

2010002400 2010002410 2020001540 2020001660 4580000110 2040000500

S.MONOLITH S.MONOLITH CERAMIC CERAMIC S.FILTER LC

FL-306 (38.850 MHz) FL-307 (38.850 MHz) [USA/-1] only CFWM450D CFG450H [USA/-1] only ACF321825-223-T BNX-002-01

X1

6050010830 S.XTAL

CR-657 (12.800 MHz)

L2 L3 L4 L5 L6 L7 L8 L9 L10 L11 L12 L14 L15 L17 L19 L20 L21 L22 L23 L26 L27 L31 L33 L35

6110001670 6110001740 6110001610 6110001610 6110001550 6170000230 6200003350 6150005000 6150005000 6150005000 6200002710 6200001630 6200003300 6200003290 6200005730 6200002380 6200008400 6200005740 6200008480 6200003590 6200003350 6200007000 6200004480 6200008270

LA-253 LA-263 LA-244 LA-244 LA-235 LW-25 ELJNC R27K-F LS-527 LS-527 LS-527 ELJFC 1R8K-F ELJNC R10K-F ELJNC R22K-F ELJNC R12K-F ELJRE 39NG-F LQN 1A 56NJ04 0.35-1.6-6TL 36N ELJRE 47NG-F 0.30-1.4-5TR 25N EXCCL3225U1 ELJNC R27K-F ELJRE 82NG-F MLF1608D R82K-T 0.26-1.0-5TL 17N

COIL COIL COIL COIL COIL COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL

[USA/-1] only

[USA/-1] only

S.=Surface mount

5-2

[MAIN UNIT] REF NO.

[MAIN UNIT]

ORDER NO.

REF NO.

DESCRIPTION

L36 L39 L40 L41 L42 L43 L48 L49 L50 L52 L53 L54 L55 L56 L57 L60 L61 L62 L63 L64 L65 L67 L68 L69 L70 L71 L72 L73 L75 L77 L78 L79 L80 L81 L82 L83 L84 L85 L86 L87

6140000670 6200004480 6200009080 6200004850 6200004480 6200004480 6110001600 6150005000 6110001730 6200004480 6190001500 6200007000 6200003310 6200003310 6200003310 6200005010 6190001510 6190001500 6190001500 6190001500 6200005010 6200008760 6200009120 6200008270 6110001520 6110002110 6200002040 6200002040 6200004480 6200009140 6190001520 6190001520 6190001520 6190001520 6200004450 6200004880 6200004880 6200004450 6190001520 6200006990

COIL S.COIL S.COIL S.COIL S.COIL S.COIL COIL S.COIL COIL S.COIL COIL S.COIL S.COIL S.COIL S.COIL S.COIL COIL COIL COIL COIL S.COIL S.COIL S.COIL S.COIL COIL COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL S.COIL

LR-89 MLF1608D R82K-T MC152-E558CN-100025=P3 MC152-E558CN-100024 MLF1608D R82K-T MLF1608D R82K-T LA-243 LS-527 LA-262 MLF1608D R82K-T HK-08S070-1310 ELJRE 82NG-F ELJFC R33M-F ELJFC R33M-F ELJFC R33M-F NL 252018T-100J HK-10S080-1210 HK-08S070-1310 HK-08S070-1310 HK-08S070-1310 NL 252018T-100J 0.26-0.9-9TR 30N 0.20-0.7-4TR 8.8N 0.26-1.0-5TL 17N LA-232 LA-382 NL 252018T-101J NL 252018T-101J MLF1608D R82K-T NL 252018T-6R8J ZBFS5101-PT ZBFS5101-PT ZBFS5101-PT ZBFS5101-PT ELJFC 6R8M-F ELJFC 3R3K-F ELJFC 3R3K-F ELJFC 6R8M-F ZBFS5101-PT ELJRE 56NG-F

R1 R2 R3 R9 R11 R12 R13 R14 R15 R17 R18 R19 R20 R21 R24 R25 R26 R27 R28 R30 R31 R34 R35 R36 R37 R38 R40 R41 R42 R43 R45 R46 R48 R49 R50 R59 R61 R62 R63 R64

7030006070 7030003480 7030003500 7030003720 7030003800 7030003730 7030003680 7030003770 7030003280 7030003280 7030003720 7030003720 7030003720 7030003640 7030003670 7030003560 7030003320 7030003470 7030003320 7030003590 7030003460 7030003470 7030003320 7030003600 7030003650 7030003460 7030003480 7030003600 7030003460 7030003500 7030003650 7030003320 7030003650 7030003750 7030003430 7310003600 7030003480 7030003440 7030003480 7030003680

S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

ERJ12YJ101U (100 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 274 V (270 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 152 V (1.5 kΩ) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 821 V (820 Ω) EVM-1XSX50 B54 (503) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 104 V (100 kΩ)

ORDER NO.

DESCRIPTION

R65 R66 R67 R68 R69 R70 R71 R72 R73 R74 R75 R76 R77 R78 R79 R80 R85 R86 R87 R95 R99 R101 R108 R110 R111 R112 R113 R114 R115 R116 R117 R118 R119 R120 R121 R122 R123 R124 R126 R127 R128 R131 R132 R148 R149 R150 R151 R152 R153 R174 R181 R182 R183 R184 R186 R187 R188 R192 R193 R194 R208 R209 R211 R212 R218 R219 R220 R221 R223 R224 R225 R226 R228 R229 R230

7030003220 7030003220 7030003220 7030003480 7030003700 7030003400 7030003280 7030003660 7030003370 7030003630 7030003340 7030003560 7030003560 7030003300 7030003340 7030003300 7030003620 7030003360 7030003330 7030003600 7030003270 7030003560 7030003440 7310003610 7030003680 7030003270 7030003620 7510001100 7030003680 7030003770 7030003800 7030003690 7030003680 7030003680 7310003580 7030003630 7030003630 7030003630 7030003560 7030003560 7030003560 7030003440 7030003560 7030003600 7030003520 7310003610 7030003500 7030003320 7030003540 7030003650 7030003700 7030003760 7030003800 7030003800 7030003700 7030003680 7030003640 7030003660 7030003400 7030003490 7030003320 7030003640 7030003540 7030003440 7030003520 7030000210 7030003550 7030000520 7030003620 7030003440 7030003560 7030003680 7030003480 7030003480 7030003520

S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

R231

7030003520 S.RESISTOR

R232 R233 R234 R235

7030003520 7030003520 7030003600 7030003600

S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

ERJ3GEYJ 150 V (15 Ω) ERJ3GEYJ 150 V (15 Ω) ERJ3GEYJ 150 V (15 Ω) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 470 V (47 Ω) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 271 V (270 Ω) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 151 V (150 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 680 V (68 Ω) ERJ3GEYJ 151 V (150 Ω) ERJ3GEYJ 680 V (68 Ω) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 221 V (220 Ω) ERJ3GEYJ 121 V (120 Ω) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 390 V (39 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) EVM-1XSX50 B14 (103) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 390 V (39 Ω) ERJ3GEYJ 333 V (33 kΩ) NTCCM1608 4LH 104KC ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 124 V (120 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) EVM-1XSX50 B15 (104) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 393 V (39 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) EVM-1XSX50 B14 (103) ERJ3GEYJ 332 V (3.3 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 471 V (470 Ω) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) MCR10EZHJ 39 Ω (390) ERJ3GEYJ 822 V (8.2 kΩ) MCR10EZHJ 15 kΩ ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) [USA/-1] only ERJ3GEYJ 472 V (4.7 kΩ) [USA/-1] only ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ)

S.=Surface mount

5-3

[MAIN UNIT] REF NO. R236 R237 R238 R239 R240 R241 R242 R243 R251 R256 R267 R273 R280 R281 R288 R289 R295 R297 R301 R321 R322 R323 R325 R327 R328 R329 R330 R331 R332 R333 R334 R335 R336 R338 R340 R342 R355 R356 R357 R358 R359 R361 R362 R363 R364 R365 R366 R367 R368 R369 R370 R371 R372 R373 R374 R375 R376 R377 R378 R379 R380 R381 R383 R386 R387 R388 R389 R390 R391 R392 R393 R394 R395 R396 R397 R398 R399 R400 R401 R403 R404 R405

[MAIN UNIT]

ORDER NO. 7030003600 7030003600 7030003600 7030003600 7030003600 7030003600 7030003600 7030003320 7030003520 7030003490 7030003560 7030003760 7030003560 7030003750 7030003440 7030003720 7030003350 7030003760 7030003600 7030003640 7030004040 7030003560 7030003370 7030003340 7030003650 7030003690 7510001000 7030003720 7030003690 7030003560 7030003770 7030004050 4610001530 7030003560 7030003410 7030003560 7030003480 7030003660 7030003800 7030003670 7030003320 7030003800 7030003450 7030003680 7030003810 7030003680 7030003680 7030003560 7030003590 7030003560 7030003560 7030003560 7030003320 7030003320 7030003680 7030003530 7030003770 7030003240 7030003560 7030003680 7030006060 7030003580 7030003560 7030003700 7030003700 7030003520 7030003490 7030003410 7030003400 7310003660 7030003580 7030003580 7030003650 7030003640 7030003640 7030003480 7030003440 7030003440 7030003480 7030003480 7030003480 7030003650

REF NO.

DESCRIPTION S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.THERMISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.TRIMMER S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 394 V (390 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 181 V (180 Ω) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 4R7 V (4.7 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 271 V (270 Ω) ERJ3GEYJ 151 V (150 Ω) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 124 V (120 kΩ) TBPS1R154K475H5Q ERJ3GEYJ 224 V (220 kΩ) ERJ3GEYJ 124 V (120 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 1R0 V (1 Ω) EVM-1XSX50 B13 (102) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 561 V (560 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 683 V (68 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 823 V (82 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 122 V (1.2 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 125 V (1.2 MΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 183 V (18 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 562 V (5.6 kΩ) ERJ3GEYJ 564 V (560 kΩ) ERJ3GEYJ 220 V (22 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 104 V (100 kΩ) ERJ12YJ100U (10 Ω) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 472 V (4.7 kΩ) ERJ3GEYJ 272 V (2.7 kΩ) ERJ3GEYJ 561 V (560 Ω) ERJ3GEYJ 471 V (470 Ω) EVM-1XSX50 B55 (504) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 153 V (15 kΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 563 V (56 kΩ)

R406 R407 R408 R409 R410 R411 R412 R413 R414 R415 R417 R418 R419 R420 R422 R423 R424 R425 R426 R427 R428 R429 R430 R431 R432 R433 R434 R435 R436 R437 R438

ORDER NO.

DESCRIPTION

7030003470 7030003700 7030003700 7030004890 7030004860 7030005260 7030003560 7030003550 7030003550 7030003440 7030003480 7030003760 7030003560 7030003480 7030003800 7030003320 7030003680 7030003600 7030003640 7030003620 7030003380 7030003560 7030003570 7030003540 7030003650 7030003640 7030003560 7030000410 7030003620 7030003440 7030003400

S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR S.RESISTOR

R440 R441 R442 R443 R444 R445 R446 R447 R448 R449 R450 R451 R452 R453 R454 R455 R456 R457 R458 R459 R460 R461 R462 R463 R464 R465 R466 R467 R468 R470 R471 R472 R473 R474 R475 R476 R478 R479 R484

ERJ3GEYJ 182 V (1.8 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYJ 154 V (150 kΩ) ERJ3GEYF 434 V (430 kΩ) ERJ3GEYF 184 V (180 kΩ) ERJ3GEYF 394 V (390 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 822 V (8.2 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 474 V (470 kΩ) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 222 V (2.2 kΩ) ERJ3GEYJ 105 V (1 MΩ) ERJ3GEYJ 101 V (100 Ω) ERJ3GEYJ 104 V (100 kΩ) ERJ3GEYJ 223 V (22 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 331 V (330 Ω) ERJ3GEYJ 103 V (10 kΩ) ERJ3GEYJ 123 V (12 kΩ) ERJ3GEYJ 682 V (6.8 kΩ) ERJ3GEYJ 563 V (56 kΩ) ERJ3GEYJ 473 V (47 kΩ) ERJ3GEYJ 103 V (10 kΩ) MCR10EZHJ 1.8 kΩ ERJ3GEYJ 333 V (33 kΩ) ERJ3GEYJ 102 V (1 kΩ) ERJ3GEYJ 471 V (470 Ω) [USA/-1] only 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) [USA/-1] only 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω) 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ) 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) 7030003700 S.RESISTOR ERJ3GEYJ 154 V (150 kΩ) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) 7030003530 S.RESISTOR ERJ3GEYJ 562 V (5.6 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) 7030006190 S.RESISTOR ERJ12YJ2R2U (2.2 Ω) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) 7030001160 S.RESISTOR MCR50JZHJ 180 Ω (181) 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) 7030003670 S.RESISTOR ERJ3GEYJ 823 V (82 kΩ) 7510001100 S.THERMISTOR NTCCM1608 4LH 104KC 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ)

C1 C2 C3 C4 C5 C6 C7

4030011210 4030011070 4030011230 4030011030 4030011180 4030011260 4030011180

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

R439

GRM42-6 GRM42-6 GRM42-6 GRM42-6 GRM42-6 GRM42-6 GRM42-6

CH 330J 500PT CH 050C 500PT CH 390J 500PT CK 1R5C 500PT CH 220J 500PT W5R 102K 500PT CH 220J 500PT

S.=Surface mount

5-4

[MAIN UNIT] REF NO. C8 C9 C10 C11 C12 C13 C14 C15 C16 C17 C18 C19 C20 C21 C22 C23 C24 C25 C26 C27 C28 C29 C30 C31 C32 C33 C34 C36 C37 C39 C40 C41 C42 C43 C44 C46 C47 C48 C50 C51 C52 C53 C54 C55 C56 C58 C59 C60 C61 C62 C63 C68 C69 C70 C71 C72 C73 C74 C75 C77 C78 C82 C85 C87 C91 C92 C95 C96 C97 C98 C99 C100 C101 C102 C103 C110 C112 C113 C114 C115 C116 C117

[MAIN UNIT]

ORDER NO. 4030007080 4030007040 4030007100 4030011260 4030011180 4030011020 4030011020 4030011180 4030011120 4030011120 4030006860 4030006860 4030011260 4030007010 4030007050 4030009560 4030006860 4030006860 4030006860 4030006860 4030006860 4030007060 4030006860 4030009500 4030007060 4030009530 4030006860 4030006860 4030006860 4030006900 4030006860 4030006900 4030006900 4030006860 4030011600 4030006900 4030011600 4030011600 4030011600 4030006900 4030011600 4030006900 4030006900 4030006900 4550006560 4510004440 4550006360 4550006150 4030006860 4030006860 4030006860 4030006860 4030006860 4030006860 4030006860 4030009990 4030006860 4030007040 4030006860 4030006860 4030009990 4030006860 4030006860 4030007030 4030006860 4030006860 4030007060 4030006860 4030006860 4030007030 4030006860 4030006860 4030007070 4030007050 4030007100 4030012600 4550006220 4510004630 4550006140 4030006860 4030006900 4030009970

REF NO.

DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.ELECTROLYTIC S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.ELECTROLYTIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC

C1608 CH 1H 390J-T-A C1608 CH 1H 180J-T-A C1608 CH 1H 560J-T-A GRM42-6 W5R 102K 500PT GRM42-6 CH 220J 500PT GRM42-6 CK 010C 500PT GRM42-6 CK 010C 500PT GRM42-6 CH 220J 500PT GRM42-6 CH 100D 500PT GRM42-6 CH 100D 500PT C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A GRM42-6 W5R 102K 500PT C1608 CH 1H 100D-T-A C1608 CH 1H 220J-T-A C1608 CH 1H R75B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 270J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A C1608 CH 1H 270J-T-A C1608 CH 1H 030B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A ECST1CY225R ECEV1HA010SR ECST1VY104R ECST1CY105R C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 200J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 180J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 200J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 270J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 330J-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 560J-T-A C2012 JB 1A 105M-T-A TEMSVA 0J 156M-8L ECEV1CA100SR ECST1EY474R C1608 JB 1H 102K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 182K-T-A

C118 C119 C120 C121 C122 C123 C124 C126 C127 C128 C129 C130 C131 C132 C133 C134 C135 C138 C139 C140 C141 C148 C149 C153 C154 C156 C164 C165 C167 C168 C170 C175 C177 C188 C189 C190 C192 C193 C195 C206 C208 C209 C211 C212 C213 C214 C217 C218 C220 C224 C226 C228 C229 C230 C231 C232 C233 C234 C235 C241 C242 C249 C250 C251 C253 C255 C256 C257 C258 C259 C260 C261 C262 C263 C264 C265 C266 C267 C268 C277 C279 C286

ORDER NO. 4030009630 4030007130 4030012610 4030006900 4030006860 4550006220 4030006860 4030011600 4030006900 4030011600 4510007460 4030006860 4030006860 4550006710 4550006140 4550006710 4030006860 4510004630 4030006860 4030006860 4030006860 4030006860 4030006860 4030012600 4030007050 4030011600 4030007010 4030007060 4030006860 4510005950 4030012600 4550006540 4550006300 4030007070 4030006860 4030009500 4030007010 4030006860 4030009990 4510006670 4030007130 4030012610 4510007320 4510007320 4030006860 4030006860 4030007080 4030006860 4030006860 4030011600 4550005980 4030006900 4030006900 4030006900 4030006860 4030010210 4030012600 4030012600 4030006900 4030011190 4030017080 4030006860 4030006860 4030006860 4030006860 4030006860 4030008880 4030009970 4030006900 4030008860 4030006860 4030008880 4030011340 4030012660 4030007120 4030011600 4030011600 4030011600 4030011600 4030006860 4030007000 4030009500

DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.TANTALUM S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC ELECTROLYTIC ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C1608 JB 1H 822K-T-A C1608 CH 1H 101J-T-A C2012 JB 1C 474K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A TEMSVA 0J 156M-8L C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N 10 SV 22M C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECST1AX226R ECST1EY474R ECST1AX226R C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C2012 JB 1A 105M-T-A C1608 CH 1H 220J-T-A C1608 JB 1C 104KT-N C1608 CH 1H 100D-T-A C1608 CH 1H 270J-T-A C1608 JB 1H 102K-T-A ECEV1HA0R1SR C2012 JB 1A 105M-T-A ECST1CY475R ECST1AY475R C1608 CH 1H 330J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 0R5B-T-A C1608 CH 1H 100D-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 200J-T-A ECEV1CA471P C1608 CH 1H 101J-T-A C2012 JB 1C 474K-T-A 50 YXG 470M 50 YXG 470M C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 390J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N TEMSVA 1A 475M-8L C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A C3216 JB 1C 105M-T-A C2012 JB 1A 105M-T-A C2012 JB 1A 105M-T-A C1608 JB 1E 103K-T-A GRM42-6 CH 270J 500PT GRH111 CH 820J 500PT C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 223K-T-A C1608 JB 1H 182K-T-A C1608 JB 1E 103K-T-A C1608 JB 1C 153K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 223K-T-A C1608 CH 1H 471J-T-A C1608 JB 1C 683K-T-N C1608 CH 1H 820J-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 0R5B-T-A

S.=Surface mount 5-5

[MAIN UNIT] REF NO.

[MAIN UNIT]

ORDER NO.

REF NO.

DESCRIPTION

C288 C289 C290 C292 C293 C295 C298 C299 C300 C301 C308 C309 C312 C313 C314 C315 C316 C317 C318 C319

4030006860 4030011600 4030011600 4030008920 4030010760 4030006860 4510006660 4030006890 4030011600 4510004540 4030006900 4030011600 4030006860 4030011600 4030011600 4030006900 4030011180 4030006900 4030006900 4030006900

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C320 C321 C322 C323 C324 C325 C326 C327 C328 C329 C330 C331 C332

4030006900 4030006860 4510005630 4030006860 4030006860 4030011600 4550006560 4030006900 4030006900 4030006900 4030011110 4030011160 4030006900

S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C333 C337 C338 C339 C340 C341 C342 C343 C344 C346

4030006900 4030011600 4030011600 4030008470 4030011600 4030006900 4030006950 4510006220 4030009500 4030006960

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC

C347 C348 C349 C353 C354 C358 C359 C360 C361

4030011600 4030006900 4030008650 4030011600 4030011600 4030007090 4030007050 4030006860 4030006950

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C362 C366 C374 C378 C379 C380 C381 C382 C383 C384 C385 C387 C388 C389 C390 C391 C392

4030006860 4030006860 4030006860 4030006870 4550006300 4550006150 4030011600 4030006900 4550006390 4030011600 4030008900 4510006670 4510005750 4030006860 4030011600 4030009500 4030007020

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.TANTALUM S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

C395 C396 C397 C398 C399 C400 C401 C402

4030006950 4030012610 4030012610 4030009000 4510006220 4510004640 4510004640 4030008980

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC

C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 473K-T-A C1608 CH 1H 331J-T-A C1608 JB 1H 102K-T-A ECEV1HA330P C1608 JF 1H 103Z-T-A C1608 JB 1C 104KT-N ECEV0JA470SR C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A GRM42-6 CH 220J 500PT C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A [USA/-1] only C1608 JB 1E 103K-T-A C1608 JB 1H 102K-T-A ECEV1EA330SP C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N ECST1CY225R C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A C1608 JB 1E 103K-T-A GRM42-6 CH 090D 500PT GRM42-6 CH 150J 500PT C1608 JB 1E 103K-T-A [USA/-1] only C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1H 272K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 CH 1H 040C-T-A ECEV1CA101UP C1608 CH 1H 0R5B-T-A C1608 CH 1H 050C-T-A [USA/-1] only C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A C1608 JB 1H 332K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 470J-T-A C1608 CH 1H 220J-T-A C1608 JB 1H 102K-T-A C1608 CH 1H 040C-T-A [USA/-1] only C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 222K-T-A ECST1AY475R ECST1CY105R C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A TEMSVA 1C 335M-8L C1608 JB 1C 104KT-N C1608 JB 1C 333K-T-A ECEV1CA471P ECEV1EA220SP C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 CH 1H 0R5B-T-A C1608 CH 1H 120J-T-A [USA/-1] only C1608 CH 1H 040C-T-A C2012 JB 1C 474K-T-A C2012 JB 1C 474K-T-A C2012 JB 1C 224K-T-A ECEV1CA101UP ECEV1CA470SP ECEV1CA470SP C2012 JB 1C 154K-T-A

C403 C404 C405 C406 C407 C409 C410 C413 C415 C416 C417 C418 C419 C420 C421 C422 C423 C424 C425 C426 C427 C428 C429 C430 C431 C433 C434 C436 C437 C438 C439 C441 C442 C443 C444 C445 C446 C447 C448 C449 C450 C452 C453 C454 C455 C456 C457 C462 C463 C468 C472 C500 C501 C502 C503 C504 C505 C506 C507 C508 C509 C512 C513 C514 C515 C516 C517 C518 C519 C520 C521 C522 C523 C524 C525 C529 C530 C531 C533 C535 C536 C537

ORDER NO. 4030012600 4030012610 4030009350 4030006960 4030009530 4030006860 4030006860 4550006160 4030007060 4030007030 4030006860 4030006860 4030001170 4030006900 4030007050 4030007070 4030006970 4030007100 4030006900 4030009990 4030007080 4030006900 4030009550 4030006900 4510006220 4510004650 4030006960 4510004630 4510004630 4030006900 4030007170 4510006220 4030006900 4030011600 4030006900 4510006220 4030010760 4030012600 4510006220 4030006900 4030010040 4510007230 4510005870 4550003210 4030006900 4030017070 4030017070 4030017070 4030017070 4030017070 4030006860 4030009650 4030007050 4030007110 4030006980 4030007150 4510007320 4510004420 4030008960 4030010020 4030010020 4030006860 4510004630 4030006860 4030006860 4030011600 4030006860 4030016990 4030011250 4030011280 4510004650 4030007050 4030006870 4030008550 4030006860 4030008920 4030008770 4510007390 4030009530 4510005520 4030011600 4030006860

DESCRIPTION S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC ELECTROLYTIC S.ELECTROLYTIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC ELECTROLYTIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.ELECTROLYTIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC ELECTROLYTIC S.CERAMIC ELECTROLYTIC S.CERAMIC S.CERAMIC

C2012 JB 1A 105M-T-A C2012 JB 1C 474K-T-A C1608 CH 1H 3R5B-T-A C1608 CH 1H 050C-T-A C1608 CH 1H 030B-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A ECST1CY155R C1608 CH 1H 270J-T-A C1608 CH 1H 150J-T-A C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A GRM42-6 B 102K 50PT C1608 JB 1E 103K-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 330J-T-A C1608 CH 1H 060D-T-A C1608 CH 1H 560J-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 200J-T-A C1608 CH 1H 390J-T-A C1608 JB 1E 103K-T-A C1608 CH 1H 2R5B-T-A C1608 JB 1E 103K-T-A ECEV1CA101UP ECEV1EA4R7SR C1608 CH 1H 050C-T-A ECEV1CA100SR ECEV1CA100SR C1608 JB 1E 103K-T-A C1608 CH 1H 221J-T-A ECEV1CA101UP C1608 JB 1E 103K-T-A C1608 JB 1C 104KT-N C1608 JB 1E 103K-T-A ECEV1CA101UP C1608 CH 1H 331J-T-A C2012 JB 1A 105M-T-A ECEV1CA101UP C1608 JB 1E 103K-T-A C1608 JB 1H 561K-T-A 50 YXG 1000UF ECEV1HA3R3SR TEMSVD2 1D 226M-12R C1608 JB 1E 103K-T-A GRM42-2 R 474K 50PT GRM42-2 R 474K 50PT GRM42-2 R 474K 50PT GRM42-2 R 474K 50PT GRM42-2 R 474K 50PT C1608 JB 1H 102K-T-A C1608 CH 1H 240J-T-A C1608 CH 1H 220J-T-A C1608 CH 1H 680J-T-A C1608 CH 1H 070D-T-A C1608 CH 1H 151J-T-A 50 YXG 470M ECEV0JV330SR C2012 JB 1C 104K-T-A C1608 JB 1H 122K-T-A C1608 JB 1H 122K-T-A C1608 JB 1H 102K-T-A ECEV1CA100SR C1608 JB 1H 102K-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A GRM42-2 R 105K 50PT GRM42-6 W5R 471K 500PT C1608 CH 1H 271J-T-A ECEV1EA4R7SR C1608 CH 1H 220J-T-A C1608 JB 1H 222K-T-A C2012 JF 1H 473Z-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 473K-T-A C1608 JB 1H 562K-T-A 50 YK 220M C1608 CH 1H 030B-T-A 50 MV 330 HC C1608 JB 1C 104KT-N C1608 JB 1H 102K-T-A


[MAIN UNIT] REF NO.

ORDER NO.

DESCRIPTION

C538 C539 C540 C541 C542 C543 C544 C545 C546 C547 C548 C549 C550 C551 C552 C553 C554 C555 C556 C557 C558 C575

4030007140 4030007010 4030006860 4030011600 4030011600 4030011600 4030007150 4030007020 4030007000 4030009650 4030006860 4030016990 4030006860 4030007090 4030009530 4550006540 4030011250 4030009650 4030009650 4030004750 4030006860 4030017070

S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.TANTALUM S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC S.CERAMIC

J5 J6 J7

6510020510 S.CONNECTOR FH12-40S-0.5SV 6510009400 CONNECTOR B7B-ZR 6450000140 CONNECTOR HSJ0807-01-010

T1

5920000750 TRANSFORMER ST-82 (P)

W1 W2 W3 W4 W15 W25 W27 W28 W29 W32 W33 W34 W35 W38 W39 W40 W41 W42 W43 W44 W46 W47 W48 W49 W51 W71

8900009210 7120000470 7120000470 7120000470 7030003860 7030003860 7030003860 7030003860 7030007150 7030003860 7030003860 7030003970 7030007150 7030000010 7030003970 7030003970 7030003860 7030003860 7030003860 7030003860 7030003860 7030000010 7030003970 7030007150 7030003860 7030003860

WS1

8970023550

EP1 EP2 EP3 EP4

0910051545 6910013270 9040901901 9040901901

CABLE JUMPER JUMPER JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER S.JUMPER

C1608 CH 1H 121J-T-A C1608 CH 1H 100D-T-A C1608 JB 1H 102K-T-A C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 JB 1C 104KT-N C1608 CH 1H 151J-T-A C1608 CH 1H 120J-T-A C1608 CH 1H 090D-T-A C1608 CH 1H 240J-T-A C1608 JB 1H 102K-T-A GRM42-2 R 105K 50PT C1608 JB 1H 102K-T-A C1608 CH 1H 470J-T-A C1608 CH 1H 030B-T-A ECST1CY475R GRM42-6 W5R 471K 500PT C1608 CH 1H 240J-T-A C1608 CH 1H 240J-T-A C2012 JB 1H 103K-T-A C1608 JB 1H 102K-T-A GRM42-2 R 474K 50PT

OPC-905 ERDS2T0 ERDS2T0 ERDS2T0 ERJ3GE JPW V ERJ3GE JPW V [GEN/-1] only ERJ3GE JPW V ERJ3GE JPW V [GEN/-1] only MCR50JZHJ JPW (000) ERJ3GE JPW V ERJ3GE JPW V MCR18EZHJ JPW (000) MCR50JZHJ JPW (000) MCR10EZHJ JPW (000) MCR18EZHJ JPW (000) MCR18EZHJ JPW (000) ERJ3GE JPW V ERJ3GE JPW V ERJ3GE JPW V ERJ3GE JPW V ERJ3GE JPW V MCR10EZHJ JPW (000) MCR18EZHJ JPW (000) MCR50JZHJ JPW (000) ERJ3GE JPW V ERJ3GE JPW V

AX2270 J LEAD SET (2) /MA

PCB BEAD TUBE TUBE

B 5318E 2643-625002 IRRAX 0.7 (d) L=12 mm IRRAX 0.7 (d) L=12 mm


SECTION 6

MECHANICAL PARTS AND DISSASEMBLY

[CHASSIS PARTS] REF. NO

ORDER NO.

[ACCESSORIES] DESCRIPTION

QTY.

REF. NO

ORDER NO.

J1

6510004880

Connector MR-DS-E 01

1

F1

5210000070

MP1 MP2 MP3 MP4 MP5 MP6 MP7 MP8 MP9 MP10 MP11 MP12 MP13 MP17

8010017870 8810008660 8810008490 8810008660 8810009130 8930050080 8820000870 8110007150 8930049650 8930036771 8930050130 8310027320 8930051440 8310048070

2270 chassis Screw PH BT M3 × 8 NI-ZU Setscrew H M2.6 × 8 NI Screw PH BT M3 × 8 NI-ZU Screw PH BT M3 × 12 NI-ZU 2270 IC clip 1705 cap screw 2270 cover Thermal sheet (H) 1705 main seal-1 2270 jack sheet Display seal (U) [USA/-1] only 2270 thermal sheet TC-200TKC Serial No seal (BE) A110 [GEN/-1] Serial No seal (BE) A110 FCC [USA/-1] 2270 B-sheet 2270 A-sponge

1 8 2 2 4 1 3 1 1 1 1 1 1

W1 W2

MP18 MP19

8930051830 8930051820

1 1 1

DESCRIPTION

QTY.

Fuse FGB 10A

2

Optional product 8900000730

DC power cable OPC-344 Microphone (HANG) cable OPC-049

1 1

MC1

Optional product

Microphone HM-100

1

MP1 MP3 MP4 MP5 MP6 MP7 MP8 MP9

8010016730 8820000530 8810000470 8810005840 8850000150 8850000390 8830000120 6910004210

150 mounting bracket Flange bolt M4 × 8 NI PH M5 × 12 (+/-) PH A M5 × 20 Flat washer M5 NI BS Spring washer M5 Nut M5 731 microphone hanger set (incl. 2 screws, 2 washers)

1 4 4 4 4 4 4

MC1

1

W1 MP9

W2

[FRONT UNIT] REF. NO

ORDER NO.

DESCRIPTION

QTY.

J2

6450001470

Connector 95003-2881

1

DS1

5030001740

LCD HLC7453-012400

1

EP2

8930037960

LCD contact SRCN-1705 ZSS

1

SP1

2510000880

Speaker SME-45W

1

MP1 MP2 MP3 MP4 MP6 MP7 MP8 MP10

8210012610 8930036830 8930036820 8930037660 8210013310 8930049760 8610009840 8810009130

1705 reflector 1705 LCD holder 1705 LCD filter 1705 LCD sheet 1705 front panel assembly 1705 front key (C) Knob N234 Screw PH BT M3 × 12 NI-ZU

1 1 1 1 1 1 1 3

MP1

MP3 MP4 MP5

MP6

Screw abbreviations

[MAIN UNIT] REF. NO

ORDER NO.

DESCRIPTION

J7

6450000140

Connector HSJ0807-01-010

QTY. 1

W1

8900009210

Cable OPC-905

1

MP1 MP2 MP3 MP4 MP5 MP6 MP7 MP8 MP9 MP11 MP12

8510011660 8930013590 8510012940 8510012950 8510012920 8510012910 8930051860 8510012960 8950000180 8930052670 8930052660

2088 VCO case Alumi sheet N 2270 IF FIL sheild 2270 A-shield plate 2270 B-shield plate 2270 rug 2270 A-sheet 2270 C-shield plate Cable tie-80 Thermally sheet Rubber sheet

1 1 1 1 1 1 1 1 1 1 1

6-1

MP7

MP8

F1

BT:Self-tapping PH: Pan head NI: Nickel NI-ZU: Nickel-Zinc BS: Brass

OPPOSITE DIRECTION TO THE MAIN UNIT MP12 (M)

MP4 (C)

MP4 (M)

J1 (C) MP11 (M) MP12 (C)

W1 (M) MP5 (M) MP9 (M) MP3 (C)

MP17 (C)

FRONT UNIT

MP6 (M) MP2 (C)

MP10 (F) MP6 (C) EP2 (F)

MP2 (C)

MP2 (M)

MP8 (M)

J2 (F) MP2 (C) MP2 (C)

MP1 (C) DS1 (F)

MP13 (C) MP9 (C)

MP2 (F) MAIN UNIT MP1 (F) MP3 (F)

MP7 (C)

MP3 (M)

MP2 (C)

MP4 (F) MP11 (C)

MP6 (F)

MP7 (F) J7 (M)

MP10 (C)

MP19 (C)

MP18 (C) MP8 (F) MP7 (C)

SP1 (F)

MP8 (C)

MP7 (C)

MP5 (C)

Unit abbreviations

(F): FRONT UNIT

(M): MAIN UNIT

6-2

(C): CHASSIS PARTS

MP5 (C)

SECTION 7

SEMI-CONDUCTOR INFORMATION • DIODES

• TRANSISTORS AND FET’S 2SA1471R

2SA1586 GR (Symbol: SG)

2SA1622 6 TL (Symbol: M6)

2SB1132 T100 R (Symbol: BART)

1SS352 (Symbol: C1)

2SB798 T2 DK (Symbol: DK)

1SV271 (Symbol: TG)

1SV307 (Symbol: TX)

DA204 U T107 (Symbol: K)

DE5SC6M-4061 (Symbol: 5SC6)

MA77 (Symbol: 4B)

MA8036 L (Symbol: 3_6)

E B

B

B C

C

BC

C

E

E

E

2SC4081 T107 R (Symbol: BR)

2SC4081 T107 S (Symbol: BS)

B

2SC4116 BL (Symbol: LL)

B C

D

2SC4211-6-TL (Symbol: L6)

2SC4215 O (Symbol: QO)

HVU350 TRF (Symbol: 4)

MA2S111 (Symbol: A)

A

MA8051 M (Symbol: 5-1)

2SD1819 A R (Symbol: LG)

MA8330 M (Symbol: 33-)

RB706F-40 T106 (Symbol: 3J)

3SK184 R (Symbol: 3R R)

2SK880 GR (Symbol: XG)

S

D

S

S G

S

G2

G

D

D

G1 D

D

G2 G1

S

S

G S

DTA143ZUA T106 (Symbol: 113)

DTA144EUA T106 (Symbol: 16)

DTB123 EK T147 (Symbol: F12)

B

B

C

E

E

MRF137 (Symbol: MRF133) G

B C E

S1

D1

G1

D1

S2

D2

G2

D2

C

E

E

XP1113 (Symbol: 7L)

XP1501 AB (Symbol: 5R)

D

B1

G

S

B C

E

FW215-TL (Symbol: W215)

DTC144EUA T106 (Symbol: 26)

DTC144 EE TL (Symbol: 26)

B

C

C

DTC114EUA T106 (Symbol: 24)

B

S

C1

B1

C1

E

E1 S

B2

C2

B2

C2

D

XP4315 (Symbol: CB) E1

C1

B1

B2

C2

E2

SB07-03C-TB (Symbol: J)

UM9401F

A

C E

G D

C

B

E

G

MA111 (Symbol: 1B)

C

C

2SK3075 (Symbol: UB F)

C

A

E

B

E

C

B

2SC4403 3 TL (Symbol: LY3)

C

2SK3074 (Symbol: UW)

A

C

B

E

2SK2414-Z-E1

E

E

C

E

E

B

2SC4228(M)-T1 R45 (Symbol: R45)

B C

C

E

2SC4226 T2 R25 (Symbol: R25)

B

C

C

E

2SC4215 Y (Symbol: QY)

B

B C

E

B

7-1

C

SECTION 8

BOARD LAYOUTS

8-1 FRONT UNIT

The combination of this page and the next page show the unit layout in the same configuration as the actual P.C.Board.

I

¡TOP VIEW

V/M

SCAN

PRI

SQL

MP2

HANG GND MIC MICE PTT AFO CLON 8V

8-1

¡BOTTOM VIEW

W1

W2

SPE

SP

4

3

5

1

J1 40

GND GND SPE SPE SP SP 8V VCC 5V FROM MAIN TRC UNIT J5 TMUT PSWC CPU5V MICE MIC PTT PTTS GND GND 2 GND

GND 39 GND RMUT AFMUT SMUT VCS SCK SO BEEP FISW UNLK PLSTB SO SCK R/T PDET SQLI GND GND 1 GND

80

61 60

1

20

41 21

4 9

16

8-2

40

1

8

1

5

8

1

8

4

5

8-2 MAIN UNIT W1

EXT SP

¡TOP VIEW

BLACK

RED

J1

The combination of this page and the next page show the unit layout in the same configuration as the actual P.C.Board.

MP4 W4

W2 W3

1

MP8

MP5 12

MP1

1

4

10

11

20 5

4

1

3

3

1

1 4 5

11

20

2 J5

4

3

5

1 4

3

5

1

40

GND GND RMUT AFMUT SMUT VCS SCK SO BEEP FISW UNLK PLSTB SO SCK R/T NC SQLI GND GND GND

5

1

GND GND SPE SPE SP SP 8V VCC 5V TRC TMUT PSWC CPU5V MICE MIC PTT PTTS GND GND GND

8

10

1

8-3

TO FRONT UNIT J1

39

W36 (RED)

W37 (BLACK)

¡BOTTOM VIEW

1

5

3

4

5

4

8

1

3

1

4

5

MP3

9

1

16

8

9

8

16 5

4

1

8

1

1 8

4

3

5

1

7

1

8

14

4

8

4

5

14

1

1

8

4

5

1

4

1

9 5

1

5

16

7 8

8

8 4

1

5

8

8-4

5

4

8

1 4

1

5

8

SECTION 9

BLOCK DIAGRAM D51~D52 1SV271 X2 Q4~Q5 2SC4215 X2

Q7 2SC4211

Q6 2SC4215

AM DET

IF AMP

FI3 CFWM450D

D44: MA8051 IC40: TA31136FN W25

W28

IF AMP

2nd IF IC

CERAMIC BPF

D50: 1SV271 Q3: 2SC4215

D30 1SV307

Q2 3SK184

D29 1SV307

FI1 FL-306

FIL SW

IF AMP

[ ANT ]

1st MIX

1st IF=38.85MHz

2nd IF=450KHz

Q1 3SK184

D7,D8 HVU350 X2

FIL SW

XTAL BPF

D6,D37 HVU350 X2

RF AMP

RF BPF

D38 1SV271

D1~D3 UM9401F X3

RX ATT

RF BPF

ANT SW

LPF

IF AGC IC18 TC4W53FU

FI4 CFG450H

W/N SW

AGC AMP

Q69 DTB123EK

IC17 TC4W53FU

BUFF [USA/-1] only

W/N SW

CERAMIC BPF

D31 1SV307

Q68 XP4315

FIL SW

BUFF [USA/-1] only

FI2 FL-307

D28 1SV307

XTAL BPF

TX & RX=118.0~136.975MHz

1st Lo:79.15MHz~98.125MHz

Q77 2SD1819A

FIL SW

Q78 2SD1819A

D53.D54: MA2S111 Q73: 2SC4081

RF AGC

AGC AMP

BUFF TUNE 2nd Lo:38.4MHz

Q42 2SC4403

IC11:NJM2107F

IC31 TA75S01F

RSSI SQL CONT

SQLI

FISW

J6 +5V

1 2 3 4 5 6 7

EXT MIC LEVEL ADJ R336

IC16 TC4W53FU

IC4: BA3308F D14: MA8036L

R110

IC51 TA75S01F

IC5 TA75S01F

EPTT AF OUT

AF AMP

ALC AMP

IC19 NJM2902V

MIC LEVEL ADJ

HPF

MOD ADJ R121

IC22 TC4W53FU MOD/AF SW

EXTMIC IN/EXT MIC SW

LPF

Q33 XP4315

ACC

TRC

Q98 2SA1586 Q15 2SC4228

Q14 2SC4403

BUFF

BUFF

IC13 TC9260F

IC30 TC4S66F

AF AMP

S MUTE SW

T1 ST-82P

E-VOL

D4,D5 RB706F X2

R150 POWER ADJ

X1 CR-657 TCXO (12.8MHz)

TX:118.0~136.975MHz RX:79.15~98.125MHz

LPF

VCO

TUNE ADJ RMUTE

Q12 2SC4403

Q43 2SC4226

BUFF

BUFF

PLL IC

S MUTE IC28 TC4S66F

J7

PWR DET

APC CNT

APC AMP

PWR CNT

T MUTE AMP

Q79 2SK880 TUNE BUFF

AF AMP

R MUTE

BEEP

D43: 1SS352 Q74: 2SB798 Q75: 2SC4081 Q86: XP4315

IC42 TA75S01F

IC50 TA75S01F

Q99 2SC4116

12.8MHz R59

IC6:TC4S66F Q80:DTA144EU Q81:DTC144EU

PWR AMP

Q11 2SC4081

PTTS

IC37 TDA7233D IMPEDANCE CONVERT

PRE DRIVE

D10,D11 MA77 X2

TMUTE

PTT CONT

PRE DRIVE

Q51 MRF137

MOD V

R/T SW

T8

R/T CONT

D27: MA111 Q52: 2SA1622

PRE AMP

Q83,Q84 2SC4215 X2

TRIPLER AMP

Q21 2SK3075

TX:118.0~136.975MHz

LPF

Q20 2SK3074

Q44: 2SC4226 D64: HVU350 TX VCO

IC2 TB31207AFN

AF MUTE EXT SP

D66: SB07-03C Q100: FW215 Q101: DTC144EU

SMUTE IC41 TA8208H

Q59: 2SC4226 D65: HVU350

LOOP FIL

RX VCO

SP MUTE

PWR AMP

MAIN UNIT

AF MUTE Q16 2SC4116

LCD BACK LIGHT DS2~DS7 CL-170Y-CD X6

+8V

Q1: DTA143ZU Q7: DTC114EU

IC5 BU4094BC

Q94 FW215 SP OUT SW

LEDC2

BUFF

8V

D62: SB07-03C Q96: DTC144EU Q97: DTC144EU

Q72: XP4315 Q53: DTB123EK S2

IC2 S-80942ANMP

CPU

VUP

D57: SB07-03C IC47: HIP4081A

SP OUT CONT

R8 SW

R8

S3

TRC

MOD/AF SW

AF

HD6433823A19D

PROTECT V/M

LINE FILTER

D56 DE5SC6M

PWM MOD

Q71: DTC144EE Q70: DTB123EK

S4

AF POWER AMP

IC44 uPC311

MOD

IC1

D6 DA204U

Q92,Q93 2SK2414 X2

FET DRIVER

IC48 TC4W53FU

RESET

VDN

VCO R/T SW

R/T

R/T CONT

EXPAND Q5: DTA143ZU Q6: DTC114EU

DS1 HLC7453-012400

RIPPLE FIL

Q4 XP4315

LEDC1

BUFF

LCD

Q58 XP1113

DC-DC DET

T8 SW

T8 S5 SCAN S6 PRI

IC26 TA78L05F

TMUT

X1 CPU5V

PBRC3.68AR (3.68MHz)

+5 REG

REF,V OSC

+8V REG

IC47A HIP4081A DC-DC CONVERT CONTROL

+5V

EEPROM

S7

+5V

IC45 NJM072BM

D35: MA8330 Q82: 2SC4081

DC-DC CONVERT AMP

FET DRIVER

IC46 MC33063AD

Q91 2SK2414

DC POWER SUPPLY 13.8V or 24.0V W1

Q2: 2SA1622 Q3: 2SC4211 D5: MA111

S8 POWER

I/O BUFF

S1

DIAL

+5V

IC4 25LC160T-I/SN

IC3 TC7W04FU

IC29 BA08FP

I/O BUFF +5V CURRENT AMP

+5V

+5V REG IC7 S-81350HG

J2 1 2 3 4 5 6 7 8

VCC

FRONT UNIT

TS

Q22: 2SC4211 Q23: 2SB1132 D15: MA111

+8V CLONE I/O PTT PSWC

MIC HANG

MIC CONNECTOR

SP SP

9-1

1

+

2

-

VCC 8V

+8V REG

D36 DSA3A1

DC-DC CONVERTOR D26 DE5SC6M LINE FILTER

DC-DC DET

POWER SW CTRL

POWER SW IC15 MC33063AD POWER AMP Q87,Q88 2SK2414 X2

FET DRIVER D55: SB07-03C IC43: HIP4081A

DC-DC CONVERT CONTROL

RX TX

POWER SW CTRL Q89 XP1501AB

PROTECT

Q102 2SC4081

Q90 2SA1471

PSWC

SQL

COMMON LINE DATA BUS LINE

SECTION 10 VOLTAGE DIAGRAM 10-1 FRONT UNIT

Dimmer OFF : 0V Light : 7.8V Dark : 6.1V

COM4 COM3 COM2 COM1 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 AEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32

C22 0.1

R27 100k

D5 MA111

R16 6.8k

L2 0.22uH

C1 0.001

CP1

C3 47p

C2 0.001

C4 47p

C5 0.001

L1 1uH

C8 470p

R29 100k

SP

8V

R38 100k +

C20 0.1

5.04V

3.0V

R34 3.3k

4

3

5

2

6

1

4.5V

R/T

EXSTB SO SCK LED1 LED2 TRC

1 2 3 4 5 6 7 8

STR D CLK Q1 Q2 Q3 Q4 VSS

VDD OE Q5 Q6 Q7 Q8 QS QS

16 15 14 13 12 11 10 9

OE TMUT RMUT AFMUT SMUT

PDET SQLI

R33 10k

R/T

1.51V

R32 10k

5.0V

IC5 BU4094BCFV

PTTS

R31 10k

Q4 XP4315

RX : 7.07V TX : 0V

10 - 1

-

W4

C28 0.001 5V

PTT MICE MIC CPU5V

R22 100k

+

J1

C26 0.1

R21 100k

W1 W2

C6 47p

C30 47p

+

C23 4.7

C7 470p

C24 0.1

C25 0.1

SP SPE

5V

C27 10

8 7 6 ECK 5 ESO

to MICROPHONE

SP1

SEG24 SEG23 SEG22 SEG21 SEG20 SEG19 SEG18 SEG17 SEG16 SEG15 SEG14 SEG13 SEG12 SEG11 SEG10 SEG9 SEG8 SEG7 SEG6 SEG5

C14 0.1

VCC HOLD SCK SI

R23 100k

CS SO WP VSS

C21 0.001

1 2 3 4

60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41

R20 100k

SCK ESI SO PLSTB FISW

R37 100k

ESI

D6 DA204U

P77/SEG24 P76/SEG23 P75/SEG22 P74/SEG21 P73/SEG20 P72/SEG19 P71/SEG18 P70/SEG17 P67/SEG16 P66/SEG15 P65/SEG14 P64/SEG13 P63/SEG12 P62/SEG11 P61/SEG10 P60/SEG9 P57/WKP7/SEG8 P56/WKP6/SEG7 P55/WKP5/SEG6 P54/WKP4/SEG5

IC1 HD6433823A19D

R19 100k

IC4 25LC160T-I/SN

8V

80 79 78 77 76 75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 PB6/AN6 PB5/AN5 PB4/AN4 PB3/AN3 PB2/AN2 PB1/AN1 PB0/AN0 AVCC P43/IRQ0 P42/TXD32 P41/RXD32 P40/SCK32 P87/SEG32/CL1 P86/SEG31/CL2 P85/SEG30/DO P84/SEG29/M P83/SEG28 P82/SEG27 P81/SEG26 P80/SEG25 PB7/AN7 AVSS X1 X2 VSS OSC2 OSC1 TEST RES P10/TMOW P11/TMOFL P12/TMOFH P13/TMIG P14/IRQ4/ADTRG P15/IRQ1/TMIC P16/IRQ2 P17/IRQ3/TMIF P30/PWM P31/UD P32/RESO

C16 0.1

R36 22k

BEEP PSWC

R10 100k

R2 100k

R3 100k

R26 100k

R24 100k

5

ECS

4 TS

ECK ESO ECS DLA DLB OE EXSTB VCS

R28 1k

COM4 COM3 COM2 COM1 SEG1 SEG2 SEG3 SEG4

PSWC BEEP

R46 27k S1 EVQB2CFC620B 2 A 3 B COM 1

4.95V

P33/SCK31 P34/RXD31 P35/TXD31 P36/AEVH P37/AEVL CVCC VSS V3 V2 V1 V0 VCC PA3/COM4 PA2/COM3 PA1/COM2 PA0/COM1 P50/WKP0/SEG1 P51/WKP1/SEG2 P52/WKP2/SEG3 P53/WKP3/SEG4

KR4 R7 15k

SQL

J2 8V CLON AFO PTT MICE MIC GND HANG

8V

21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40

C10 30p

R45 15k

HANG

LED1 LED2 PTTS HANG PDET SQLI

C33 0.001

C34 0.001

0.1 R1 1M

R6 15k

R15 18k

HANG

C18 0.001

C17 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

C9 X1 30p PBRC3.68AR

KR3

4.75V

Q3 2SC4211

R9 100k

R47 15k

PRI S7

C35 0.001

KR4 KR2 R5 15k

SCAN S6

C12 0.1

R44 15k

R17 33k

8 7 6 5 0V

C36 0.001

KR1 R4 15k

C11 0.027

R43 15k

IC2 S-80942ANMP-DD6 1 5 CD 2 OUT 3 VDD 4 VSS NC

C29 0.001

S5

KR1 KR2 KR3

R8 10k

V/M

1 2 3 4

C31 0.001

C19 0.001

R42 27k

VDN S4

CLO CLIN

PSW CLO CLIN UNLK SEG32 SEG31 SEG30 SEG29 SEG28 SEG27 SEG26 SEG25

C15 47p R41 27k

VUP S3

PSW

Q2 2SA1622

IC3 TC7W04FU

C32 0.001 RX : 0V TX : 4.95V

S2

8V LED2 LED1

R30 10k

S8 POWER

8V LED2 LED1

R14 47k


C13 0.1

Q7 DTC114EU

R18 100k

Q1 DTA143ZU R13 180

5V

DS7 CL-170Y-CD

Q6 DTC114EU

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36

DS6 CL-170Y-CD

Q5 DTA143ZU

COM4 COM3 COM2 COM1 SEG1 SEG2 SEG3 SEG4 SEG5 SEG6 SEG7 SEG8 SEG9 SEG10 SEG11 SEG12 SEG13 SEG14 SEG15 SEG16 SEG17 SEG18 SEG19 SEG20 SEG21 SEG22 SEG23 SEG24 SEG25 SEG26 SEG27 SEG28 SEG29 SEG30 SEG31 SEG32

DS5 CL-170Y-CD

R12 180

8V

DS2 CL-170Y-CD

LEDC1

DS3 CL-170Y-CD

CP4

W3

DS4 CL-170Y-CD

R11 270

LEDC2


DS1 HLC7453-012400

GND GND GND GND RMUT SPE AFMUT SPE SMUT SP VCS SP SCK 8V SO VCC BEEP 5V FISW TRC UNLK TMUT PLSTB PSWC SO CPU5V SCK MICE R/T MIC PDET PTT SQLI PTTS GND GND GND GND GND GND

39 37 35 33 31 29 27 25 23 21 from Main 19 Unit J5 17 15 13 11 9 7 5 3 1

10-2 MAIN UNIT

COMPLETE VIEW

8V VCC

R18 220k

D7 HVU350

C407 3p

R8

C502 68p

C501 22p

C217 39p

C500 24p

C103 56p

C100 0.001

L21 36nH L15 0.22uH

C168 0.1

C24 0.001

R14 560k

C329 0.01

C102 22p

L35 17nH

VCC

C167 0.001

R101 10k

R431 6.8k

VCC

TX: 0 V RX: 7.09 V

1

W48

D65 HVU350

C545 12p

C547 24p L41 MC152E558CN100024

R459 10k

L82 6.8uH

L40 MC152E558CN100025

8 7 6 5 4 3 2 1

R71 47

FIN2 BS2 BS1 STB DATA CLK GND FIN1

CP2 GND LD BO XOUT XIN VCC CP1

C71 0.001

C506 33 C214 0.001

R64 100k

C63 0.001

C323 0.001 TX: 7.95 V RX: 0 V

C538 120p

IC2 TB31207AFN 9 10 11 12 13 14 15 16

R243 100

W47

C195 20p

R256 2.7k

C544 150p

W49

R436 33k

Q84 2SC4215

D64 HVU350

L85 6.8uH

C59 0.1 W46 R376 560k

C427 39p

C425 0.01

R374 100k

C424 56p

L42 0.82uH

Q83 2SC4215

C226 4.7 2

VCON GND

VCC OUT

4 3

R218 4.7k

W38 C402 0.15

1

C213 0.001

X1 CR-657

Q71 DTC144EE

C558 0.001

L77 6.8uH

C206 470

C429 2.5p

MOD R8 8V VCC T8 5V

L33 0.82uH

C537 0.001

R251 4.7k

R61 TX: 7.05 V 2.2k RX: 0.54 V

C288 0.001

CP2

R335 1

2

L43 0.82uH

R475 4.7k

3

L57 0.33uH

C428 0.01

R373 100 L56 0.33uH

C430 0.01 C422 33p

C426 20p

C348 0.01

C177 4.7

5V R181 150K

R131 1k

TX: 2.4 V RX: 2.44 V

R450 10k

4

C60 1 R358 82k

C61 0.001

R59 50k

L55 0.33uH

C423 6p

TX: 0 V RX: 6.04 V

5V

Q70 DTB123EK

C409 0.001

R75 150

3

R194 2.7k

L39 0.82uH C193 0.001

C124 0.001

5

2

C277 0.001

C123 15

R63 2.2k

C122 0.001

C325 0.1

Q58 XP1113 1

TX: 0 V RX 2.96 V

BEEP

R186 150k

R73 270

TX: 5.42 V RX: 5.44 V

R379 100k

8 7 6 5 4 3 2 1

4 5

AF

8V VCC 5V

SCK SO PLSTB SP

R8 MOD AF

UNLK

TMUT

8V

5V

RMUT

MOD R8 8V VCC

TX: 4.98 V SQL Open: 5 V Q80 DTA144EU SQL Close: 0 V

5V

C337 0.1

C313 0.1

Q81 DTC144EU

Q1 2S

L14 0.1uH

C77 0.001

TX: 5.02 V RX: 5.11 V

C74 18p

R74 39k

C555 24p

R449 47

C556 24p

R76 10k

R78 68

R80 68

D10 MA77

R77 10k

C251 0.001

C92 0.001

R86 220 R85 33k C289 0.1

R359 100

C417 0.001 MOD R8 8V VCC T8 2nd LO TUNE

R367 10k

R365 100k

5V R132 10k C127 0.01

CX CS AGND LD2 LD1 IN OUT VSS

R62 1k

8V SMUT VCS SCK SO

C126 0.1

R415 1k

R375 5.6k

C421 22p

2nd LO

IC6 TC4S66F

W33

R12

R13 100k

C25 0.001

C26 0.001

R15 47

C27 0.001

C175 4.7

C29 27p

R17 47

R19 220k C30 0.001

R20 220k

C32 27p TUNE

C521 4.7

C96 0.001 L17 0.12uH

R87 120

C85 0.001

W29

R357 1M

CP1 TX: 2.0 V RX: 2.04V R372 100

TRC

R362 1.2k

R381 15k C431 100

DATA STB AGND LD2 LD1 IN OUT VDD

L67 30nH

5V

C314 0.1

3

AFMUT

6

2

R432 56k

5

1

C472 0.001

5V

IC13 TC9260F 9 10 11 12 13 14 15 16

Q15 2SC4228

C418 0.001

Q16 2SC4116

4.02 V

6

C354 0.1

5 4

1

1 5 + 4 3 — 2

R187 100k

IC28 TC4S66F

2

R8

5V TRC

R378 10k

3

4

R21 47k

C552 3p C95 27p

2nd LO TUNE 1st LO TX

R8

C265 0.1

C349 0.0033

5V 1

C78 20p

TX: 7.1 V RX: 7.13 V

Q79 2SK880

IC42 TA75S01F

C507 0.1

3

1

C128 0.1

C82 0.001

L87 56nH

R/T

C153 1

5

R366 100k

2

Q21 2SK3075

1st LO

R364 1.2M

R363 100k 4

8V VCC 5V

10 - 2

5V

R242 22k

C116 0.01

3

D11 MA77 R79 150

Q42 2SC4226

8V SMUT VCS

R467 1M

R361 1M

C378 0.0022 C383 3.3

C382 0.01

4 5

2

Q86 XP4315

R323 10k

SMUT

R322 4.7 8V VCC 5V

Q75 2SC4081

6

SO 5V

IC30 TC4S66F

C353 0.1

D43 1SS352 R325 270

C343 100

R321 47k

C387 470 R380 10

C381 0.1

C312 0.001

T1 ST-82(P)

C384 0.1

C551 47p L86 ZBFS5101-PT

C380 1

a

(EXT SP)

5 OUTPUT 6 SVR 7 —INPUT 8 +INPUT C379 4.7

C550 0.001

J7

Q74 2SB798

C374 0.001

5V VCC 8V

4 +VS 3 GND 2 MUTE 1 GND

R188 47k

C338 0.1

TX: 8.28 V SQL Open: 8.3 V SQL Close: 0.3 V R273 470k

IC37 TDA7233D

7 6 5 4 3 2 1

C114 0.47

OUT2 NC VCC ALC NC GND OUT1

8V SMUT

R383 10k

R340 560

W15

R444 10k

R336 1k

C404 0.47

1

C87 15p

8V

Q33 XP4315

R117 1M

R112 39 C112 15

NC IN2 NF2 NF1 NC IN1 NC

D14 MA8036

8 9 10 11 12 13 14

R114 NTCCM16084LH

8V MICE

MICE

5

C420 0.01 IC4 BA3308F

EMIC EPTT AFOUT

C113 10

R113 33k

C115 0.001

R108 1k

W71 C403 1

8V

2

TX: 5.31 V RX: 0 V

5V

MOD

R111 100k

L23 25nH

MOD R301 22k

1 2 3 4

7 6 5

R110 10k

C309 0.1 R476 1k

R338 10k

J6

R226 100k

R225 10k

PTT MIC

1 2 3 4

7 6 5

D27 MA111

TX: 0 V RX: 8.05 V

C110 1

4

R/T

C264 82p

C522 22p

IC22 TC4W53FU

IC16 TC4W53FU 8

R223 33k

R224 1k

C341 0.01

PTTS

Q52 2SA1622

3

R241 22k

TX: 2.17 V RX: 2.05 V

R474 4.7

T8

C290 0.1

C262 470p

TX: 2.14 V RX: 2.05 V C263 0.068

C267 0.1

C261 0.022 R240 22k

2 4 + 1 IC19a 3 NJM2902V — 11 TX: 2.17 V RX: 2.05 V

5V TX: 4.96 V RX: 0 V

FISW

C320 0.01

R479 NTCCM16084LH

IC19d NJM2902V 13 14 — 12 +

8

TX: 2.15 V RX: 2.03 V

R239 22k

L22 47nH

C519 470p

T8

C385 0.033

C119 100p

C118 0.0082

R478 82k

C58 1 IC19b NJM2902V 5 + 7 6 —

R238 22k

W20

IC31 5 TA75S01F 1 + 4 3 — 2

R124 39k

TUNE R8

VCC

SQLI

R183 1M

R342 10k

C121 0.01 R123 39k

C117 0.0018

R281 390k

5V VCC 8V

R122 39k

R356 68k

R334 560k R237 22k

C260 0.001

IC19c NJM2902V 10 + 8 9 —

TX: 2.18 V RX: 2.05 V

R116 560k

37

RF AGC

5V C433 4.7

R332 120k

C56 2.2

Q78 2SD1819A

C259 0.015

C339 0.0027

C257 0.0018

R236 22k C256 0.022

R235 22k

Q1 3SK184

0V Q68 XP4315

R182 470k

R330 TBPS1R154K475H5Q

TX: 2.28 V RX: 2.3 V

5V

RSSI

R355 2.2k

C233 1

C234 1

R49 390k R48 56k

C52 0.1

R46 100

IC51 TA75S01F 5 1 + 4 3 — R234 2 22k

35

39

L73 100uH

C509 0.0012

R329 120k R120 100k

C543 0.1

1 5 + 4 3 — 2

5V

C258 0.01

C541 0.1

C542 0.1

RSSI

TX: 2.07 V RX: 2.05 V

R456 220k

IC5 TA75S01F 1 5 + 4 3 — 2

Q77 R333 2SD1819A 10k

R331 220k

5V IC11 NJM2107F

R184 1M

TX: RX:

TX: 0.39 V RX: 2.08 V

RF AGC

TX: 10.43 V RX: 10.45 V

5.0 V TX: 0 V RX: 0.52 V

R328 56k

C54 0.01

R42 1.5k

R41 22k

C328 0.01

R38 1.5k

D51 1SV271

C55 0.01

5V

PTT SQLI PTTS

33

R484 3.9k

C268 0.1

31

Q6 2SC4215

Q7 2SC4211

C229 0.01

29

C53 0.01 TX: 0 V RX: 0.94 V

Q69 DTB123EK

Q20 2SK3074

C98 15p

R99 39

R8

L19 39nH

C99 0.001

R8

C91 0.001

C101 33p

2nd LO

C97 0.001

2nd LO

R435 1.8k

L20 56nH

IF AGC

L54 82nH

FISW

L26 EXCCL3225U

5V

C416 15p

5V FISW

C340 0.1

27

TX: 0 V RX: 1.88 V

R457 150k

25

C51 0.01

R371 10k

R455 1.2k

23

R370 10k

R454 4.7k

21

R118 120k

19

R119 100k

17

TX: 0 V RX: 2.14 V

R36 22k

15

C47 0.1

C266 0.1

13

Q4 2SC4215

R35 100

R115 100k

11

C50 0.1 TX: 0 V RX: 2.13 V

C327 0.01

SMUT SP VCS SP SCK 8V SO VCC BEEP 5V FISW TRC UNLK TMUT PLSTB PSWC SO CPU5V SCK MICE R/T MIC

R45 56k

R37 56k

SPE

9

L10 LS-527

RF AGC

R95 22k

C37 0.001

C40 0.001

5V FISW

TX: 0 V RX: 4.83 V

R50 820

AFMUT

7

Q5 2SC4215

D52 1SV271

R40 2.2k

SPE

R43 3.3k

L72 100uH

C48 0.1

R174 56k

C508 0.0012

C154 22p

RMUT

5

C34 0.001

C149 0.001

R25 10k R8

C319 0.01 U

TUNE R8

R8

3

R24 82k

C36 0.001

R28 100

R26 100

R231 4.7k U

C346 5p U C392 12p U

Q2 3SK184

R229 2.2k

D28 1SV307 U

R439 470 U

C361 4p U

R228 2.2k

R438 470 U

R230 4.7k U

C39 0.01 R368 18k

C332 0.01 U

TX: 0 V RX: 5.6 V

0V

1st LO

C415 27p

IF AGC

1

L11 LS-527

R377 22

RF AGC W51

FISW

C235 0.01

FISW

C41 0.01

D31 1SV307 U

R369 10K

Q3 2SC4215

C228 0.01

C44 0.1

R288 1k

4

C42 0.01

16 15 14 13 12 11 10 9

MIXIN GND N-REC N-DET RSSI IFOUT QUAD AFOUT

OSCIN OSCOUT MIXOUT VCC IFIN DEC FILOUT FILIN

FI2 FL-307 U

C28 0.001

D8 HVU350

C33 3p

C318 0.01

C533 3p

C31 0.5p C255 0.001 L12 1.8uH

R232 4.7k

R233 4.7k

D29 1SV307 C434 5p

C344 0.5p

R448 680

R27 1.8k

FI1 FL-306

R447 1.2k

W27

R30 18k

R437 1k

C43 0.001

C315 0.01

R327 150 1 2 3 4 5 6 7 8

1 2 3 4

7 6 5

1 2

IC40 TA31136FN

R31 1.5k

8

FI4 CFG450H U

D44 MA8051

C390 0.1

IC17 TC4W53FU U

5

to FRONT Unit J1

C156 0.1

I

3

C333 0.01

W25

8 7 6 5

TX: 0 V RX: 3.77 V

C170 1

O

1 2 3 4

R34 1.8k

TX: 0 V RX: 5.9 V

FI3 CFWM450D

IC18 TC4W53FU U C46 0.01

C224 0.1

C230 0.01

W28

J5

D30 1SV307

R8

C395 4p

R8

D50 1SV271

Note U : [USA/-1] only

MOD V

L62 HK-08S0701310

L6 LA-235

R470 22k

C468 0.47

R408 150k

L61 HK-10S080-1210

C524 0.047

C452 1000

C575 0.47

C463 0.47

C462 0.47

C457 0.47

C456 0.47 C455 0.01

C454 22

R267 10k

1 2 3 4 5 6 7 8 9 10

R407 150k

C300 0.1

BHB BHI DIS VSS BLI ALI AHI HDEL LDEL AHB

Q91 2SK2414-Z

R2 2.2k

C553 4.7

GN2

C19 0.001

CP3

2

1

C531 220

C535 330

R405 56k

3 4 5 6

CP4

R406 1.8k

D36 DSA3A1

EP2

C557 0.01

8 DRVC 7 LPKSEN 6 VCC 5 COMPIN

2

+

— W1

L79 ZBFS5101-PT R401 2.2k

13.72 V

C211 470

6

5

4 Q89 XP1501

R395 56k

5

1

3

C295 0.001

R399 1k

R398 2.2k

C447 1

R397 47k

W34

2

R400 1k

R393 15k

R414 8.2k

R411 390k

R443 10k

Q90 2SA1471R

R396 47k

C449 0.01 + —

3

R394 15k

7

— +

C444 0.01

C443 0.1

8

2

R412 10k C135 0.001

C134 22

C446 330p

1

4

5.0 V

D15 MA111

C445 100

R413 8.2k

R409 430k

R410 180k

6 7 8 R442 10k

C133 0.47

R126 10k

C132 22

G

R127 10k

4 3 2 1

R392 500k

AF MOD 5V

5

IC45 NJM072BM

C448 100

L65 10uH

Q22 2SC4211

O C131 0.001

C130 0.001

C129 22

C322 33

R472 100k R403 2.2k

C536 0.1

C523 0.0022

R121 100k

R422 1M C141 0.001

R151 3.3k

R149 4.7k

C62 0.001 C321 0.001

1 SWC 2 SWE 3 TIMCAP 4 GND

1

C450 560p

C138 10

R423 100 C512 0.001

1 2 3 4

7 6 5

FI6 BNX-002-01

IC46 MC33063AD

VCC 5V

IC43 HIP4081AIB

R391 470

C442 0.01

C441 100

R388 4.7k

R212 1k

8 DRVC 7 LPKSEN 6 VCC 5 COMPIN R211 6.8k

C439 220p

IC15 MC33063AD 1 SWC 2 SWE 3 TIM CAP 4 GND

R390 560

C232 1

C231 0.001

C212 470

C292 0.047

Q88 2SK2414-Z

1 2 3 4 5 6 7 8 9 10

VCC

VCC AFMUT

AF MOD 5V

VCC

5V

TRC

C293 330p

VCC


R389 2.7k

D26 DE5SC6M

10.45 V

BHO BHS BLO BLS VDD VCC ALS ALO AHS AHO

R387 150k

R445 820

W35

20 19 18 17 16 15 14 13 12 11

R386 150k

TX: 0 V SQL Open: 4.9 V SQL Close: 0 V

C438 0.01

C436 10 W43

D62 SB07-03C

W44

TX: 0 V RX: 7.93 V

10.1 V

L60 10uH

R440 10k

L53 HK-08S070-1310

MOD AF

D55 SB07-03C C437 10

R441 3.3k

1 S1 2 Q1 3 S2 4 G2

C518 1

8 D1 7 D1 6 D2 5 D2

Q87 2SK2414-Z

R418 470k

Q96 DTC144EU

R419 10k

Q97 DTC144EU

R434 10k

R433 47k

R466 10k R465 10k

6

Q94 FW215

Q101 DTC144EU VCC

R463 470k

5

1 S1 2 Q1 3 S2 4 G2

R464 3.3k

2

8 D1 7 D1 6 D2 5 D2

R462 10k

4 C347 0.1

Q72 XP4315 3

D66 SB07-03C

C549 1

C317 0.01

C326 2.2

Q100 FW215

R420 2.2k

C505 470 Q53 DTB123EK

R417 2.2k

MOD V

C530 0.0056

TMUT VCC 8V R8

(W37)

PSWC

C308 0.01 C208 R446 100p 8.2k

R208 100

C397 0.47

C396 0.47

C400 47

C401 47


D56 DE5SC6M

W32

MOD V TMUT VCC 8V

C324 0.001

R68 2.2k R69 150k

R70 470

C69 0.001

IN1 NF1 GND MF2 IN2 RIP OUT2 BOOT2 GND VCC BOOT1 OUT1

GN1

C120 0.47

R128 10k

L84 3.3uH

G

I

5.0 V

C529 0.047

C389 0.001

8V VCC 5V

L81 ZBFS5101-PT

TX: 1.69 V RX: 0 V

IC7 S-81350HG-KD

O

R404 2.2k

C525 0.001

R66 15

R192 68k

C189 0.001

C190 0.5p

L31 82nH

R67 15

I

1

a

SCK SO PLSTB SP

R8 MOD AF

W4

TRC

8V

R209 47k

C399 100

C209 0.47

(ANT)

L80 ZBFS5101-PT

IC47 HIP4081AIB 20 19 18 17 16 15 14 13 12 11

C253 0.001

C148 0.001

C12 22p

C13 1p C16 10p L75 0.82uH C410 0.001 C513 10

R153 6.8k

C139 0.001

R152 100

C516 0.1

C517 0.001

R193 470

C75 0.001 C548 0.001

C286 0.5p

C68 0.001

VCC C388 22

R148 22k

Q23 2SB1132

VCC

R8

C402 0.15 R335 1

2 IC50 TA75S01F

R280 10k

10.44 V

IC41 TA8208H

C398 0.22

W38

1 + 3 —

4

8

IC44 uPC311G2

IC29 BA08FP

Q12 2SC4403

12 11 10 9 8 7 6 5 4 3 2 1

C206 470

5

C140 0.001

MOD V

R71 47

8 7 6 5 4 3 2 1

C71 0.001


Q102 2SC4081

5V AF MOD

TX: 3.64 V RX: 3.65 V

C70 0.001

FN

R471 22k

IC48 TC4W53FU

VCC

C188 33p

R458 1k

L41 MC152E558CN100024

C546 9p C279 9p

C547 24p

R65 15

TX: 0 V RX: 0.8 V

R461 5.6k

C545 12p L85 6.8uH

C544 150p

D65 HVU350

Q99 2SC4116

TMUT

Q43 2SC4226 R460 4.7

FI5 ACF321825-223

TX: 3.72 V RX: 3.73 V

C391 0.5p

Q59 2SC4226 L42 0.82uH

R425 22k

R424 100k

C540 0.001 L83 3.3uH R453 1k

C192 10p

C539 10p R452 5.6k

L82 6.8uH

L40 MC152E558CN100025 R459 10k

C537 0.001 C288 0.001

R256 2.7k

C538 120p

PSWC

R150 10k TX: 1.03 V RX: 0 V

Q44 2SC4226 C195 20p

R426 47k C514 0.001

R427 33k

0V

C73 0.001 R450 10k

C193 0.001

R451 4.7

L78 ZBFS5101-PT

T8

D4 RB706F-40

R3 3.3k C18 0.001 MOD V

C249 0.001

C250 0.001 R72 68k

Q11 2SC4081

R194 2.7k

D64 HVU350

R429 10k

C515 0.001

TX: 2.44 V RX: 0 V

R428 330

T8 Q14 2SC4403

L14 0.1uH

C409 0.001

TX: 6.68 V RX: 0 V

R430 12k

L33 0.82uH

R1 100

L64 HK-08S0701310

T8

Q98 2SA1586

C72 20p

R73 270

TX: 5.42 V RX: 5.44 V

C14 1p

D5 RB706F-40

MOD V

L7 LW-25

C11 0.001

T8

C74 18p

R74 39k

R415 1k

Q82 2SC4081

I

39.7 V

TX: 7.94 V RX: 0 V T8

G

D35 MA8330 C20 0.001

C17 10p

DC2 C419 0.001

L50 LA-262

C15 22p

L71 LA-382

13.53 V

C218 0.001

C413 1.5

R220 8.2k

R221 15k

C100 0.001

L70 LA-232

Q51 MRF137 R219 39

C168 0.1

C301 47 C366 0.001

R473 180

C316 22p

C554 470p

C241 27p

R468 2.2

L36 LR-89

C520 270p

O

Q92 2SK2414-Z

MOD V

C220 0.001

L69 17nH C504 150p

C503 7p

C502 68p

L68 8.8nH

C501 22p

C217 39p

L35 17nH

C500 24p

L67 30nH

D54 MA2S111

IC26 TA78L05F

CPU5V

R297 470k

D53 MA2S111

RF AGC

C418 0.001

TX: 0 V RX: 0.83 V Q73 2SC4081

C242 82p

R8

C360 0.001

5.03 V

TUNE R8

L63 HK-08S0701310

D57 SB07-03C

Q93 2SK2414-Z

C298 33

C330 9p

C299 0.01

C2 5p

C453 3.3

C331 15p

C4 1.5p

CHASSIS J1

DC1

L48 LA-243

C1 33p

L2 LA-253

C3 39p

C7 22p

C8 39p

L3 LA-263

L52 0.82uH

C9 18p

C6 0.001

W3 W2

CP5

C5 22p

L4 LA-244 D1 UM9401F

L5 LA-244

D3 UM9401F

C362 0.001

D2 UM9401F

D38 1SV271 R295 180

C164 10p L27 0.27uH

L9 LS-527

C10 56p

C21 10p

C405 3.5p

D6 HVU350

C406 5p R289 220k

C165 27p

C22 22p

D37 HVU350

R11 1M

R12 270k

R13 100k

C25 0.001

C26 0.001

L49 LS-527

C359 22p

Q1 3SK184

C342 4p

L8 0.27uH

C23 0.75p

C358 47p

RF AGC

R15 47

CP6

TX: 0 V RX: 1.7 V

TX: 0.39 V RX: 2.08 V

R9 220k

TX: 0 V RX: 5.6 V

MOD V

(W36) CP7

VCC

COMPLETE VIEW

10-2 MAIN UNIT

R470 22k

C553 4.7

C468 0.47

C462 0.47

C457 0.47

C456 0.47

C463 0.47

1 2 3 4 5 6 7 8 9 10

L61 HK-10S080-1210

C524 0.047

C452 1000

C575 0.47

GN2

R408 150k

C1 33p

D57 SB07-03C C455 0.01

C454 22

R267 10k

D56 DE5SC6M


R407 150k

C298 33

C3 39p

D35 MA8330


Q91 2SK2414-Z

CP3

2

1

C531 220

C535 330

R405 56k

3 4 5 6

CP4

R406 1.8k

D36 DSA3A1

EP2

C557 0.01

R472 100k R403 2.2k

C536 0.1

C523 0.0022

R121 100k

R422 1M

2

+

— W1

L79 ZBFS5101-PT

C141 0.001

R151 3.3k

R149 4.7k

R401 2.2k

C211 470

R394 15k

5

4 Q89 XP1501

R395 56k

5

1

R399 1k

C447 1

W34

2

3

R400 1k

R393 15k

R414 8.2k

R411 390k

13.72 V

C295 0.001

+ —

6

R398 2.2k

MOD V TMUT VCC 8V

Q90 2SA1471R

R396 47k

C449 0.01

— +

C444 0.01

C443 0.1

7

3

R412 10k R443 10k

C134 22

R128 10k

C446 330p

8

2

4

5.0 V D15 MA111

C133 0.47

C445 100

R413 8.2k

R409 430k

R442 10k

O R126 10k

R392 500k

6 7 8

1

R397 47k

Q22 2SC4211

4 3 2 1

R410 180k

5

IC45 NJM072BM

C448 100

L65 10uH

W32

AF MOD 5V R127 10k C131 0.001

G

5.0 V

C132 22

I C130 0.001

O

8 DRVC 7 LPKSEN 6 VCC 5 COMPIN

1 SWC 2 SWE 3 TIMCAP 4 GND

C120 0.47

C135 0.001

IC7 S-81350HG-KD

C129 22

C322 33

C321 0.001

G

1

C450 560p

C138 10 C512 0.001

1 2 3 4

7 6 5

FI6 BNX-002-01

IC46 MC33063AD

TX: 1.69 V RX: 0 V

C232 1

C231 0.001

C212 470

C292 0.047

Q88 2SK2414-Z

IC43 HIP4081AIB

R391 470

C442 0.01

C441 100

R388 4.7k

IC15 MC33063AD 8 DRVC 7 LPKSEN 6 VCC 5 COMPIN R212 1k

1 SWC 2 SWE 3 TIM CAP 4 GND

R211 6.8k

VCC

1 2 3 4 5 6 7 8 9 10

C439 220p

D26 DE5SC6M

10.45 V


R390 560

R445 820

W35


R389 2.7k

TX: 0 V SQL Open: 4.9 V SQL Close: 0 V

C438 0.01

C436 10 W44

20 19 18 17 16 15 14 13 12 11

R387 150k

D62 SB07-03C

L53 HK-08S070-1310 TX: 0 V RX: 7.93 V

10.1 V

L60 10uH C437 10

R441 3.3k C518 1

8 D1 7 D1 6 D2 5 D2 1 S1 2 Q1 3 S2 4 G2

W43 R418 470k

Q96 DTC144EU

D55 SB07-03C

R440 10k R419 10k

Q97 DTC144EU

R434 10k

R466 10k

Q87 2SK2414-Z

R386 150k

C529 0.047

R433 47k

6

Q101 DTC144EU

R465 10k

5

1

Q94 FW215 VCC

R463 470k

2

D66 SB07-03C

R464 3.3k

4

1 S1 2 Q1 3 S2 4 G2

R462 10k

3

8 D1 7 D1 6 D2 5 D2

C347 0.1

Q72 XP4315

C549 1

C317 0.01

C326 2.2

Q100 FW215

R420 2.2k

C505 470

R417 2.2k

MOD V

Q53 DTB123EK C308 0.01

C208 R446 100p 8.2k

(W37)

TRC

C62 0.001

R67 15 C324 0.001

R68 2.2k R69 150k R208 100

C397 0.47

GN1

R2 2.2k 2 IC50 TA75S01F

C293 330p

4 5

L81 ZBFS5101-PT

PSWC

C530 0.0056

VCC

W4

C19 0.001 R423 100 4

R280 10k

R148 22k

R404 2.2k

C525 0.001

R66 15

L31 82nH

R192 68k

C189 0.001

C190 0.5p

C69 0.001

R70 470

R209 47k

(ANT)

L80 ZBFS5101-PT

IC47 HIP4081AIB 20 19 18 17 16 15 14 13 12 11

C253 0.001

C148 0.001

C12 22p

C13 1p C16 10p L75 0.82uH C410 0.001 C139 0.001

R427 33k

C513 10

R152 100 C515 0.001

R428 330

C516 0.1

C517 0.001

R193 470

C75 0.001

C140 0.001

1 + 3 —

C540 0.001 L83 3.3uH L84 3.3uH R458 1k

C279 9p

12 11 10 9 8 7 6 5 4 3 2 1

IN1 NF1 GND MF2 IN2 RIP OUT2 BOOT2 GND VCC BOOT1 OUT1 C396 0.47

R218 4.7k

C401 47

3

5

8V

C389 0.001

OUT

R425 22k

R424 100k

8

Q23 2SB1132

I

R8

C402 0.15

VCC

GND

C558 0.001

L77 6.8uH

VCON

W38

Q102 2SC4081

IC48 TC4W53FU

MOD V C68 0.001

IC41 TA8208H

C398 0.22

R471 22k

10.44 V

VCC

C209 0.47

L78 ZBFS5101-PT

FI5 ACF321825-223

IC44 uPC311G2

IC29 BA08FP

Q12 2SC4403

R71 47

8 7 6 5 4 3 2 1

C71 0.001


C188 33p

C399 100

C63 0.001

CP2 GND LD BO XOUT XIN VCC CP1

Q82 2SC4081

I

5V AF MOD

TX: 3.64 V RX: 3.65 V

C70 0.001

C213 0.001

2

4

C429 2.5p

1

C546 9p

IC2 TB31207AFN 9 10 11 12 13 14 15 16

PSWC

VCC

TX: 0 V RX: 0.8 V

R461 5.6k

C547 24p L41 MC152E558CN100024

R65 15

Q43 2SC4226 R460 4.7

G

TX: 3.72 V RX: 3.73 V

C391 0.5p

C400 47

W48

C545 12p L85 6.8uH

D65 HVU350

C206 470 Q71 DTC144EE

R453 1k

R256 2.7k

C539 10p C192 10p

C538 120p L40 MC152E558CN100025

C544 150p

R436 33k

W49

R243 100

C506 33

C195 20p

C548 0.001

W46 R376 560k

C427 39p

L57 0.33uH

C428 0.01

L42 0.82uH

R64 100k

X1 CR-657

TX: 1.03 V RX: 0 V

O

Q92 2SK2414-Z

T8

R150 10k

Q59 2SC4226

C425 0.01

Q84 2SC4215

D64 HVU350

R459 10k

L33 0.82uH

L82 6.8uH

R61 TX: 7.05 V 2.2k RX: 0.54 V

C537 0.001

R251 4.7k

R451 4.7 Q44 2SC4226

C288 0.001

CP2

R426 47k

Q99 2SC4116

TMUT

C286 0.5p

TX: 0 V RX: 7.09 V

C59 0.1

TX: 2.4 V RX: 2.44 V

L43 0.82uH

R452 5.6k

4

R153 6.8k

MOD V

C249 0.001

C250 0.001

0V

R194 2.7k R450 10k

3

L39 0.82uH C193 0.001

5

2

C277 0.001

C123 15

R63 2.2k

C124 0.001

Q58 XP1113

R429 10k

Q11 2SC4081

C73 0.001

R73 270

C409 0.001

R75 150

TX: 2.44 V RX: 0 V

R72 68k

L14 0.1uH

R74 39k

C77 0.001

Q98 2SA1586 TX: 6.68 V RX: 0 V

C72 20p

Q14 2SC4403

L64 HK-08S0701310

T8

R430 12k

1

R1 100

D4 RB706F-40

C514 0.001

T8

C18 0.001

VCC L15 0.22uH

C555 24p

C556 24p

R76 10k

D10 MA77

R449 47

R77 10k

R78 68

Q15 2SC4228

IC26 TA78L05F

C299 0.01

C5 22p

C331 15p

Q93 2SK2414-Z

39.7 V

D5 RB706F-40

MOD V

L7 LW-25

C11 0.001

T8

C74 18p

TX: 5.42 V RX: 5.44 V

C60 1 TX: 7.95 V RX: 0 V

C214 0.001

C323 0.001 C226 4.7

MOD R8 8V VCC T8 5V

C330 9p

C453 3.3

C301 47 L6 LA-235

R3 3.3k

C419 0.001

DC2

C20 0.001

C14 1p

13.53 V

C218 0.001

L50 LA-262

C15 22p

L71 LA-382

C17 10p

Q51 MRF137

C413 1.5

R220 8.2k

R221 15k

C100 0.001

C168 0.1

C167 0.001

L70 LA-232

C316 22p

R473 180

C242 82p

C554 470p

L36 LR-89

R468 2.2

R297 470k

C520 270p

T8

C388 22

1

R415 1k

R335 1

2

C2 5p

L63 HK-08S0701310

MOD V

C241 27p

D54 MA2S111

C220 0.001

L69 17nH C504 150p

C503 7p

C502 68p

L68 8.8nH

C501 22p

C217 39p

C500 24p

L35 17nH

R475 4.7k

3

D3 UM9401F

C7 22p

C8 39p

C9 18p

C366 0.001

D53 MA2S111

C24 0.001

C329 0.01

R14 560k R101 10k

R431 6.8k

C521 4.7

C99 0.001

C97 0.001 C251 0.001

C92 0.001 R80 68 C122 0.001 R374 100k

W47

C348 0.01

C177 4.7

R181 150K

R131 1k

C4 1.5p

CHASSIS J1

DC1

L48 LA-243

CPU5V

TX: 7.94 V RX: 0 V

Q83 2SC4215

5V

5V

L2 LA-253

C300 0.1

C360 0.001

R8

R8

C103 56p

R99 39

L21 36nH

C101 33p

C102 22p

L20 56nH

L26 EXCCL3225U VCC R86 220 C85 0.001 C325 0.1 C424 56p

L56 0.33uH

R373 100

C426 20p

C422 33p

L55 0.33uH

TX: 0 V RX: 6.04 V

BEEP

R186 150k

L3 LA-263

R379 100k

8 7 6 5 4 3 2 1

C6 0.001

D1 UM9401F

L4 LA-244

D2 UM9401F

L5 LA-244

L52 0.82uH

C164 10p L27 0.27uH

C362 0.001

R295 180

C21 10p L8 0.27uH

C405 3.5p

D6 HVU350 C22 22p

R9 220k

C406 5p R289 220k

R11 1M

R12 270k

R13 100k

C25 0.001

C26 0.001

R15 47

C27 0.001

C175 4.7

R17 47

C29 27p

R19 220k C30 0.001

TUNE

R25 10k R85 33k C417 0.001

C289 0.1

R359 100 R358 82k

R59 50k

C61 0.001 C430 0.01

C423 6p

C421 22p

Q70 DTB123EK

C127 0.01

CX CS AGND LD2 LD1 IN OUT VSS

R132 10k

R187 100k

C431 100

D37 HVU350

R18 220k

D7 HVU350

C407 3p

D8 HVU350 C32 27p

R21 47k

C552 3p C34 0.001 C416 15p C96 0.001 L17 0.12uH

R87 120

MOD R8 8V VCC T8 2nd LO TUNE

R367 10k C153 1

R365 100k R366 100k

5V

R362 1.2k

R381 15k R378 10k

L67 30nH

R375 5.6k

8V SMUT VCS SCK SO

W33

AF

8V VCC 5V

8V VCC 5V

VCC 5V

VCC

VCC AFMUT

AF MOD 5V

MOD AF

VCC

5V

TMUT VCC 8V R8

R8 MOD AF

a

SCK SO PLSTB SP

R8 MOD AF

UNLK

TMUT

RMUT

8V

TX: 4.98 V SQL Open: 5 V Q80 DTA144EU SQL Close: 0 V

TRC

Q81 DTC144EU

5V

IC6 TC4S66F

MOD R8 8V VCC

5V

5V

6

DATA STB AGND LD2 LD1 IN OUT VDD

C418 0.001

C78 20p

TX: 5.02 V RX: 5.11 V

TX: 0 V RX 2.96 V

CP1 TX: 2.0 V RX: 2.04V

2nd LO

TRC

C126 0.1

C337 0.1

3

C313 0.1

5

9 10 11 12 13 14 15 16

R62 1k

5V

IC13 TC9260F

2

W29

R357 1M

4.02 V 5V TRC

C314 0.1

1

AFMUT

4

1 5 + 4 3 — 2

6

C354 0.1

5 4

R95 22k

2nd LO TUNE 1st LO TX

R8

5V 5V

C420 0.01 IC28 TC4S66F

R432 56k

1

R467 1M

3

L87 56nH

TX: 7.1 V RX: 7.13 V

R372 100

8V SMUT VCS

C128 0.1

D38 1SV271

Q16 2SC4116

Q79 2SK880

IC42 TA75S01F

8V VCC 5V

10 - 2

C265 0.1

C349 0.0033

R301 22k

R363 100k C114 0.47

R117 1M

1

R8

L62 HK-08S0701310

TX: 0 V RX: 0.83 V

R219 39

R/T

R364 1.2M

C507 0.1

2

1

C82 0.001

R241 22k R242 22k

C116 0.01

C113 10

R361 1M

C378 0.0022

3

D43 1SS352

4 5

2

Q86 XP4315

SMUT

R322 4.7 8V VCC 5V

5

Q21 2SK3075

1st LO

SO 5V

IC30 TC4S66F

C353 0.1

R323 10k

C383 3.3

C343 100

R321 47k

C387 470 R380 10

C382 0.01

C312 0.001

T1 ST-82(P)

R325 270

C551 47p L86 ZBFS5101-PT

Q75 2SC4081

C384 0.1

(EXT SP)

C380 1

a

C381 0.1

J7

Q74 2SB798

5 OUTPUT 6 SVR 7 —INPUT 8 +INPUT C379 4.7

4 +VS 3 GND 2 MUTE 1 GND

C550 0.001

C374 0.001

5V VCC 8V

R273 470k IC37 TDA7233D

4

2

C338 0.1

TX: 8.28 V SQL Open: 8.3 V SQL Close: 0.3 V

R383 10k

R340 560

W15

R444 10k

R336 1k

C404 0.47

3

C10 56p

W3 W2

CP5

Q73 2SC4081

RF AGC

L23 25nH

C472 0.001

R/T

8V SMUT

8V VCC

MICE

R79 150

Q42 2SC4226

8V

Q33 XP4315

R188 47k

8V MICE

EMIC EPTT AFOUT

7 6 5 4 3 2 1

C115 0.001

OUT2 NC VCC ALC NC GND OUT1

NC IN2 NF2 NF1 NC IN1 NC

R114 NTCCM16084LH

D14 MA8036

R110 10k

8 9 10 11 12 13 14

R112 39

8V

R113 33k

IC4 BA3308F

C112 15

R338 10k

R476 1k

R111 100k

R474 4.7

MOD

C264 82p

C522 22p

1 2 3 4

L22 47nH

D11 MA77

6

MOD

R108 1k

W71 C403 1

R226 100k

R225 10k

PTT MIC

C110 1

1 2 3 4

7 6 5

D27 MA111

R223 33k

R224 1k TX: 0 V RX: 8.05 V

J6

8

C87 15p

C290 0.1

C262 470p

2 4 + 1 IC19a 3 NJM2902V — 11 TX: 2.17 V RX: 2.05 V

14

7 6 5

IC16 TC4W53FU

C309 0.1

Q52 2SA1622

C341 0.01

PTTS

TX: 5.31 V RX: 0 V

5

1

C267 0.1

C261 0.022

IC19d NJM2902V 13 — 12 +

C165 27p

L9 LS-527

TUNE R8

T8

5V

4

2 C320 0.01

R478 82k

C58 1

R240 22k

C98 15p

T8

C385 0.033

C119 100p

R239 22k

5V TX: 4.96 V RX: 0 V

SQLI

R479 NTCCM16084LH

TX: 2.14 V RX: 2.05 V C263 0.068

TX: 2.17 V RX: 2.05 V

W20

8

TX: 2.15 V RX: 2.03 V

FISW

C95 27p

R356 68k IC19b NJM2902V 5 + 7 6 —

R238 22k C260 0.001

R237 22k

C259 0.015

IC19c NJM2902V 10 + 8 9 —

IC22 TC4W53FU

IC31 5 TA75S01F 1 + 4 3 — 2

R124 39k

C118 0.0082

RF AGC

5V C433 4.7 C56 2.2

R332 120k

C257 0.0018

C339 0.0027

C256 0.022

R236 22k

TUNE R8

VCC

Q68 XP4315

Q78 2SD1819A

L49 LS-527

C342 4p

0V

R183 1M

R342 10k

C121 0.01 R123 39k

C117 0.0018

R281 390k

5V VCC 8V

R122 39k

1 5 + 4 3 — 2

3

TX: 2.18 V RX: 2.05 V

R116 560k

37

RSSI

R334 560k

R48 56k

C52 0.1

R46 100

R235 22k

Q20 2SK3074

5V

R182 470k

R330 TBPS1R154K475H5Q

TX: 2.28 V RX: 2.3 V

5V

RSSI

R355 2.2k

C233 1

C234 1

R49 390k

L73 100uH

C509 0.0012 R45 56k

C328 0.01

R329 120k R120 100k

C543 0.1

Q77 R333 2SD1819A 10k

Q1 3SK184

C519 470p

R435 1.8k

IC11 NJM2107F

R184 1M

C23 0.75p

C358 47p

RF AGC

TX: 10.43 V RX: 10.45 V

5V

C258 0.01

C541 0.1

C542 0.1

R456 220k

1 5 + 4 3 — 2

IC51 TA75S01F 5 1 + 4 3 — R234 2 22k

L19 39nH

R8

TX: 2.07 V RX: 2.05 V

35

39

C54 0.01

R42 1.5k

R41 22k C327 0.01

IC5 TA75S01F

C91 0.001

5.0 V

C229 0.01

PTT SQLI PTTS

33

D51 1SV271

5V

C415 27p

2nd LO

Q69 DTB123EK

TX: 0 V RX: 0.52 V

R328 56k

C268 0.1

31

Q7 2SC4211

R331 220k

C340 0.1

29

C53 0.01 TX: 0 V RX: 0.94 V

Q6 2SC4215

C55 0.01

R457 150k

27

TX: 0 V RX: 1.88 V

R455 1.2k

25

C51 0.01

R371 10k

R484 3.9k

R454 4.7k

23

R370 10k

R118 120k

21

C47 0.1

R119 100k

19

R36 22k

17

TX: 0 V RX: 2.14 V

C266 0.1

15

Q4 2SC4215

R35 100

R115 100k

13

C50 0.1 TX: 0 V RX: 2.13 V

R38 1.5k

SMUT SP VCS SP SCK 8V SO VCC BEEP 5V FISW TRC UNLK TMUT PLSTB PSWC SO CPU5V SCK MICE R/T MIC

11

TX: 0 V RX: 4.83 V

R37 56k

SPE

9

R40 2.2k

R50 820

C48 0.1

AFMUT

7

Q5 2SC4215

D52 1SV271

SPE

R43 3.3k

R174 56k

L72 100uH

C508 0.0012

C154 22p

RMUT

5

L10 LS-527

CP6

TX: 0 V RX: 1.7 V

TX: 0.39 V RX: 2.08 V

RF AGC

L54 82nH

FISW

R8

3

R24 82k

C149 0.001

R26 100

5V

2nd LO

IF AGC

C37 0.001

W51

C40 0.001

5V FISW

TX: 0 V RX: 5.6 V

MOD V

(W36) CP7

5.03 V

TUNE R8

R8

C319 0.01 U

C392 12p U

Q2 3SK184

C36 0.001

R231 4.7k U

R28 100

D28 1SV307 U

R8

1

L11 LS-527

R377 22

0V

1st LO

R229 2.2k

R439 470 U C346 5p U

C361 4p U

R228 2.2k

FI2 FL-307 U

R438 470 U

R230 4.7k U

R31 1.5k

C332 0.01 U

C28 0.001

R20 220k

R27 1.8k

L12 1.8uH

C318 0.01

C33 3p

C255 0.001

C533 3p

R233 4.7k

C434 5p

C344 0.5p R232 4.7k

C31 0.5p

C359 22p

D29 1SV307

R448 680

RF AGC

5V FISW

IF AGC

C39 0.01 C41 0.01

R368 18k

Q3 2SC4215

D31 1SV307 U

R369 10K

16 15 14 13 12 11 10 9

MIXIN GND N-REC N-DET RSSI IFOUT QUAD AFOUT

OSCIN OSCOUT MIXOUT VCC IFIN DEC FILOUT FILIN

C42 0.01

C228 0.01 FISW

FISW

LEFT SIDE

MOD V

FI1 FL-306

R447 1.2k

W27

R30 18k

R437 1k

C43 0.001

C315 0.01

R327 150 1 2 3 4 5 6 7 8

C44 0.1

R288 1k

4

C235 0.01

5

IC40 TA31136FN

1 2 3 4

7 6 5

1 2

D44 MA8051

C390 0.1

8

FI4 CFG450H U 3

to FRONT Unit J1

C156 0.1

I IC17 TC4W53FU U

7 6 5

TX: 0 V RX: 3.77 V

C170 1

O

C333 0.01

W25

8

1 2 3 4

R34 1.8k

TX: 0 V RX: 5.9 V

FI3 CFWM450D

IC18 TC4W53FU U C46 0.01

C224 0.1

C230 0.01

W28

J5

D30 1SV307

R8

C395 4p

R8

D50 1SV271

Note U : [USA/-1] only

VCC

RIGHT SIDE

6-9-16, Kamihigashi, Hirano-ku, Osaka 547-0002, Japan Phone : 06 6793 5302 Fax : 06 6793 0013

< Corporate Headquarters > 2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Phone : (425) 454-8155 Fax : (425) 454-1509 URL : http://www.icomamerica.com < Customer Service > Phone : (425) 454-7619

3071 #5 Road, Unit 9, Richmond, B.C., V6X 2T4, Canada Phone : (604) 273-7400 Fax : (604) 273-1900 URL : http://www.icomcanada.com

A.C.N. 006 092 575 290-294 Albert Street, Brunswick, Victoria, 3056, Australia Phone : 03 9387 0666 Fax : 03 9387 0022 URL : http://www.icom.net.au

6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C. Phone : (02) 2559 1899 Fax : (02) 2559 1874

Communication Equipment Himmelgeister Str. 100, D-40225 Düsseldorf, Germany Phone : 0211 346047 Fax : 0211 333639 URL : http://www.icomeurope.com

Crta. de Gracia a Manresa Km. 14,750 08190 Sant Cugat del Valles Barcelona, SPAIN Phone : (93) 590 26 70 Fax : (93) 589 04 46 URL : http://www.icomspain.com

Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K. Phone : 01227 741741 Fax : 01227 741742 URL : http://www.icomuk.co.uk

Zac de la Plaine, Rue Brindejonc des Moulinais BP 5804, 31505 Toulouse Cedex, France Phone : 561 36 03 03 Fax : 561 36 03 00 URL : http://www.icom-france.com

6-9-16, Kamihigashi, Hirano-ku Osaka 547-0002, Japan

S-13608HI-CD c 2000 Icom Inc.

IC-A110 Service Manual - shercoares.org

Recommend Documents